Table 1 shows one common tire related problems of the 2019 Volvo S60.
| Problem Category | Number of Problems |
|---|---|
| Tire problems |
Have there been complaints about the pirelli tires with foam inlays falling apart because the foam comes unattached, then causing misalignment. Car becomes unsafe to drive as the tires start to disintegrate. My car started shaking so bad it became difficult to drive. Turned out foam inlay had become unattached which caused uneven wear and some tire disintegration along with the alignment getting out of whack. Tire size 235/40r19 96v pirelli p-zero - it happened with all four tires. Two in the front were relatively new and had less than 10000 miles on them.
Sudden, extreme vibration of front tires on I-95 west palm beach FL. Drove immediately to schumacher Volvo to keep initial service appointment. Service manager advised to replace all 4 tires due to previous experience with oem perelli tire failures on Volvo vehicles. Replaced all 4 tires at costco at $1112+ cost. All photos show failure of foam/padding inside tires by pirelli p zero run flat. Tire size: 235/40/19 xl.
235/40/19 xl run flat: at 20,750 miles, sudden extreme vibration at interstate speed. Confirmed by schumacher Volvo service on 28 oct 2023. Service writer and technician advised tire/s failing due to 'foam' separating inside tire. Rotated tires and could not determine which tire. Advised to replace all tires due to experience with same problem on same tires. Recommended purchasing another brand at costco.