Volvo XC60 owners have reported 6 seats related problems since 1996. Table 1 shows the 1 most common seats problems. The number one most common problem is related to the vehicle's seats (6 problems). For details of each of the problem category, use the links in the table.
| Problem Category | Number of Problems |
|---|---|
| Seats problems |
Hello, thanks for your time. I purchased my Volvo Xc60 in late 2020 from my local Volvo manhattan dealership. The vehicle was certified pre-owned with approximately 28k miles on it, and in excellent condition. Less than three years later, I have encountered a material airbag safety issue with a prohibitively high repair cost. The passenger occupant seat sensor has failed (srs airbag warning light is now on), which means that the passenger airbag no longer functions. This requires a full seat replacement at an exorbitant cost ($4,000+ including parts and labor). The vehicle only has 48k miles driven. I have a family and find it unacceptable that my vehicle is essentially no longer usable unless I make a very expensive repair. I feel this should be 100% covered by Volvo given the vehicle has <50k miles and it is a material safety issue. Thank you. Best, john.
It was explained to me that since the back rear seat in the Volvo Xc60 seatbelt had a fault that it alerted the srs airbag system. In event of a crash the airbags in my car would not deploy and that the only remedy was to replace the entire seatbelt in the Volvo. To prove this point I took my car in to a Volvo dealership and the technicians offered the fix as the only way my cars airbags would work if I got it fixed.
Have brought car twice for vibration and shutter when vehicle is driven on highway. The shutter is extreme and only stops when car comes to a dead stop at an intersection or toll. Increasing speed or lowering speed does not stop the extreme shutter felt in wheel and passenger compartment. Car has only 37,000 miles on odometer! this extreme vibration and shutter is intermittent and not all the time. This problem has been previously reported to NHTSA as propeller shaft front head on awd system. Portland Volvo has done alignment on 10/10/22, but could not find reason for shutter/shimmy. Brought car back to dealer on 10/27/22 and they found nothing. Bringing car back to dealer on 11/16/22 for same problem.
Without warning, car loses blis, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Adaptive bending lights go off intermittently and headlamp malfunction warning on dash.
Every time it rains water runs in from sunroof and or front windshield got to where you can't even drive in the rain anymore it is so bad. Still has the factory windshield in the car.