Table 1 shows one common other fuel system related problems of the 2019 BMW X3.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
I'm reporting a safety issue with BMW vehicles equipped with the b58 engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drive train malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs $6,000-$8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.
On returning to my locked vehicle that had been in the parking ramp for 3 days, I started the car and the display message indicated that my vehicle was completely out of gas and the oil was very low. The vehicle had nearly a full tank of gas when it was parked. The vehicle was towed to the dealership who assessed the vehicle. The service department indicated that the vehicle likely did not sound like it was running because of the idle feature, and as such, I may have thought I shut off the car, but that eventually the idle feature turned off, and the vehicle ran while it was locked until it was out of gas. The service man who sent me a video of my vehicle and described what happened, also showed me another BMW SUV in the hoist next to my vehicle and indicated that same vehicle had the same thing happen as well. BMW replaced the programing/encoding control units software that was original to the vehicle. They indicated that this would improve overall function of the vehicle. The cost of this replacement was $371. This sounds like a design flaw. How can a locked vehicle start back up after a period of time, by itself with no vehicle fob in the vicinity, and run for hours until it is out of gas and the oil is low?.
I am reporting repeated coolant system failures and overheating on my 2019 BMW X3 . I have had 4 coolant-related repairs in under 3 years, including the coolant reservoir boiling after service. Most recently, the problem recurred despite prior repairs. This is a certified pre-owned vehicle with warranty history, and I believe this is a systemic engine/cooling defect that poses a risk of engine failure or fire. Other owners may be affected. A recall or investigation is warranted.