Five problems related to electrical system have been reported for the 2000 Chevrolet Astro. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2000 Chevrolet Astro based on all problems reported for the 2000 Astro.
Rear a/c switch burned up. Smelled plastic burning , saw smoke came out of rear a/c switch on dash. Popped off switch and found burned switch and wires.
- the contact stated that 2000 Chevrolet Astro LS' locks failed, not allowing her to gain entrance to the vehicle on October 18, 2006. The failure was due to the door lock actuator melting. The contact stated that the vehicle was towed to eagle automotive. The mechanic replaced the actuator, but removed the relay because the circuit was continuously closed. The mechanic said that if they didn't remove the relay it would melt the actuator again. The contact stated that she believed the failure will reoccur. The contact stated that she went to monument Chevrolet and asked for a print out of the maintenance repairs. The contact found that this vehicle has been repaired on April 3, 2001 for back door locks and again on February 14, 2002 for the sliding door. The actuator assembly on the right was also replaced on the driver door. The contact stated that the driver door and the sliding door were the only doors on the vehicle that had functioning locks. The contact stated that all of the other door lock handles werestuck and couldn't be pulled to lock or unlock the doors. She has tried to get resolution from the manufacturer, and they said that because it was not towed to a dealership they would not reimburse her for any repairs. The manufacture was given a file #1-438966317. The contact also sent pictures to the manufacturer of the burnt out actuators and with a certified letter. The consumer stated the brakes failed, however she was told nothing was wrong. The consumer was told the brakes were designed to fail on uneven pavement under 25 mph. The troqued converter burned out. The locks had an electrical short. Updated 03/19/07.
Turn signal switch bad////// no brake lights.
Vehicle, hesitates and shuts off while driving. . . Loss of power steering / brakes. . . . And won't "re-start" 1 ] 05. 08. 01 8:00pm - 10692 miles . Vehicle died while pulling out of gas station drive way. ( yes, caused traffic!) 2] 05. 15. 01 7:00pm - 10855 miles . Only 163 miles from prior service. . . Waiting for traffic light. . . Vehicle shuts off! 3] 10. 17. 01 11:00pm - 15080 miles . Vehicle cranks but won't start! 4] 07. 15. 02 11:58pm - 22363 miles . Vehicle, hesitaes and shuts-off, whle drviing! loss of power steering / brakes! 5 ] 01. 17. 02 8:30pm - 28181 miles. Pulling out of "home" driveway, vehicle shuts-off! ( two tow trucks had to come out and pull me out!).
The vehicle cranks but would not start due to broken electrical connection. Yh.