general problems of the 2002 Chevrolet Astro

Vehicle lost all electrical power to every system that is controlled by the ignition being turned on. Driver was in the process of making a u-turn around a curbing island in the divided traffic road when all electrical was interrupted while the steering wheel was turned all the way to the left. Condition caused steering to become difficult, brake pedal went clear to the floor, air conditioning and radio and headlights all went off. Condition was repeatable with exception of brake pedal, each time steering was turned to the left. Inspection under vehicle found that main power cable is routed across front side of main frame motor mount member. There was a slight curve in the way the wire was routed and each time the steering was turned to the left, the inner tie rod end for the right wheel came in contact with the wire harness. After many miles, the protective cover and then the actual wire insulation was rubbed through. This caused a direct short to ground through the steering parts of all (switched while running) electrical components of the vehicle. Problem was corrected by taping the wire insulation, then taping the protective covering. I then had to fabricate a bracket to screw to the steel crumple member to hold the harness back from the steering linkage.

Abs was activated at slow speeds causing a substantial drop in braking power.

Abs coming on at very low speeds on dry pavement (under 5mph/8kmh). It doesn't do it every time, but quite often at low speeds, like coming to a red light, stop sign or parking. Of course, there is no need for the abs come on at such low speeds and especially not on dry pavement.

The contact owns a 2002 Chevrolet Astro van. The contact stated that while driving in reserve at approximately 5 mph, the brakes and the power steering malfunctioned. The vehicle was towed to a local mechanic. The mechanic could not remedy the problem. The contact stated that the vehicle was unsafe to drive. The failure mileage was 25,000.

Tl. Contact owns a 2002 chevy Astro van. Current mileage was 97,000 and failure mileage were 50,000. Contact stated upon purchasing the vehicle from enterprise car rental the brakes have been bad. Contact stated that the vehicle has been in the shop over 20 time most of the time for the brakes. Contact has crash the due to the brakes on the vehicle. Contact feels thatthe vehicle was a lemon upon purchase and does not feel this vehicle should be on the road. Jo.

When the brakes were applied, the pedal traveled to the floor. Also lost steering control. Blown power steering shaft seal had to be replaced.