Air Conditioner Problems of Chevrolet Astro

The vehicle's air conditioner failed. The window on the passenger side door needed to be repaired.

See all problems of the 1999 Chevrolet Astro 🔎.

Air conditioner controls overheated.

See all problems of the 1998 Chevrolet Astro 🔎.

Brake problems on 1997 Chevrolet Astro van. The consumer stated that more brake work was needed. The brakes had rusted and needed to be turned, the a/c was not blowing cold and there was a heating concern. The rear axle seals and differential gaskets were leaking. .

See all problems of the 1997 Chevrolet Astro 🔎.

Air conditioning lines are rubbing a hole against both fuel lines on driver's side. There is no rubber insulation between hoses.

See all problems of the 2000 Chevrolet Astro 🔎.

We noticed a smell of burning wires. We were parked, so I pulled the rear a/c switch out of the dash. I found that this switch, which is all plastic, had been shorted and partially melted. I disconnected the switch. The scary part for me is that the fuse never blew. I am an aircraft mechanic and feel that I was able to avoid an electrical fire by having some mechanical ability. If my wife had been in the van alone with our children this would have been a very serious and possibly devastating problem. I contacted the manufacturer and lodged a complaint with Chevrolet customer assistance ( file # c01463026 ). Chevrolet told me that no recall had been issued on this switch and that all I could do is take it to the dealer. The dealer wants to put in a replacement switch, same type. This type of switch, in my opinion, is unsafe and a hazard, and I refuse to put this type of switch back into my vehicle.

Sometimes windshield wipers work fine/some times windshield wipers will go fast, even on intermittent basis, and some times they don't work at all. There was a recall on wipers mulfunctions during the previous year and the consumer believes that this problem is the same as the 95 models. The a/c hose assembly failed twice and was repaired, but it failed again.

See all problems of the 1996 Chevrolet Astro 🔎.

Design defect corrected in new installation. However, out $432 to cover fix for known problem. Gm refused to cover loss even though a design change had been made. No safety defect mentioned in the summary.

Air conditioning hose leaking.

Air conditioner vent replaced. Mjs.

Air conditioner knob inoperative.

Air conditioner knob failed.

Air conditioner compressor failed.

Temperature control switch failed.

Air conditioner failed.

Chevrolet doesn't care about using cheap parts- after warranty they say trade it in . Numerous things wrong with van and have talked to Chevrolet many times. Can't use back door of van, run out of gas, knobs fall of interior devices, asked chevy to help since 37,000 and problems still happening as I go, can't afford to fix and can't afford to trade. Another nice shove it job by Chevrolet they don't stand by their prduct and their product is not safe please respond.

Dealer not fixing problems with brakes and drive terrain. Chevrolet no help in repair either. Please help! mr.

See all problems of the 2001 Chevrolet Astro 🔎.

While parked air conditioner exploded. Dealer has been notified. Please provide further details.

A/c compressor failed causing noise.

Consumer states when air conditoner is set on maximum air comes out of defroster instead of all the other air ducks. It's intermittent.