Brake Disc Rotor problems of the 2003 Chevrolet Impala

The intermediate steering shaft in my 2003 Chevrolet Impala had to be replaced at 25,000 miles. Now at 45,000 miles the steering shaft needs to be replaced again also, both rear brake rotors were replaced at 25,000 and need to be replaced again at 45,000 miles.

20003 Chevrolet Impala with 45,242 miles needed brake rotors turned due to warping. $190.

: the contact stated while the vehicle was at the service dealer for an oil change, the service technician determined that the break rotors were cracked. The break rotors and break pads were replaced.

At about 45,000 miles the brake warning tab started making the scratching noise when I put on the brakes. Two days later the car was in the shop for front brake service. I was expecting just pads were needed, but not the case. I was told and shown the rotors had worn down too far to cut. Both front rotors were below safe depth. I could not believe this with only 45,000 on the car. The rotors were junked and my repair bill went to twice as much. Is this american quality or what! other than this, I have and do like my Impala. Chevy could call and make this right would put thing 100% right with me. Will they do that??? jb.

Our 2003 Impala LS @ 50k miles had a vibration when the brakes were applied that greatly increased with harder braking and also a steady vibration from the front end that increased as speed increased. My retired father in law brought the car to the dealer where we purchased the car, brian harris Chevrolet in baton rouge, la and he felt that he was treated poorly by the service dept. We then took the car to all star Chevrolet where we were treated professionally. They diagnosed the problems, front wheel bearings and warped rotors, but said that they could not repair it under warranty until it was approved by the warranty carrier, which could take several days. They said that rental car reimbursement would be made if warranty repair was approved. We paid a diagnostic fee and picked up our car and then took it to our local independent repair shop that we have dealt with for years and paid for the repair ourselves. They resurfaced the brake rotor and replaced the left front hub assembly. Now @ 80k miles we are experiencing the same warped rotor problems again.

At app. 32,000 miles I had my brakes checked and needed to replace 2 rotors. The vehicle is a 2003 Impala, not driven in heavy traffic, the terrain is flat, mild winters with little road salt exposure. Old parts not available.

: the contact stated the rear rotors rusted. This was first noticed while changing the front brakes. Even though the rear rotors were rusted the rear brake pads were fine. The manufacturer determined the rotors may have rusted due to the environment. Updated 01/25/06.

Experiencing clunk in steering; also failed rotors.

The rear rotors had to be replaced and the front rotors turned. Eleven months later, both sets of rotors were defective again. When touching the brakes they pulsated. The manufacture stated that brakes were considered a wear item.

2003 chevy Impala, bought new. All four brakes wore out prematurely. Warped, scored rotors. Car still under warranty, but not rotors. Dealership was notified, but was unable to resolve the problem. They said my driving habits and the climate were to blame. I've been driving gm cars in this area for 40 years, and never had this problem. Called Chevrolet customer care center to report defective parts. Have parts. Claim denied. I had my own mechanic replace parts with heavy duty rotors. Lightweight rotors should never be standard on cars sold on lots in north conway, nh.

Noticed increasing noise and vibration when applying brakes. Took car in for safety inspection and front brake service. Was informed the rear rotors are badly rusted and corroded , may not be improved by grinding or turning, and might need to be replaced, and the linings are at 20-25% on the front and 15-20% on the rear. I pointed out that the service garage had done a safety inspection a little less than a year ago and documented that the rear brakes were ok, and the front brakes had 50% of the lining left. Called Chevrolet customer care center and spoke with delosha payne, who called the service department, called me back and informed me that the rear brakes wore at a faster rate than the front, and whoever rotated my tires should have checked the rotors and informed me they needed service. I had asked this garage about rotating the tires at both inspections and neither time did anyone indicate it should be done. I think they should have recommended it.

Front brake rotors wore out, causing heavy vibration in the vehicle when braking. Dealership was notified, but was unable to resolve the problem. The dealer replaced the warped rotors and cleaned the pads but the vibration recurred. The consumer had two different technicians fax him a copy of general motor documents pertaining rotor problems.

Brakes made grinding noise when applied ( 7403 miles ), pulsation heard and felt,right rear rotor severally pitted,turnedremaining 3 rotors and sanded pads. Performed road variation test on tires right front failed and was replaced. At 15334 miles same problem, surface of rotors found to be very corroded,resurfaced front brake rotors and replaced rear brake rotors, also sent a product report to gm and attention of shop foreman and factory rep. At 18728 miles rotors corroded again resurfaced. This is third time for brake problems I am not confident in driving this 2003 chev Impala and I have heard numerous complaints for the same problem ( unsafe ) the factory rep. Offered me $1000 voucher toward a new car. I have all the names and documention in my files.

When driving at different speeds and applying the brakes there was a severe vibration in the steering wheel. The consumer contacted the dealership and was informed by the mechanic that a possible cause was warped brake rotors. The dealer replaced the warped rotors. The problem would occur when the vehicle reached between 12 and 15 thousand miles.

The steering wheel started to vibrate while driving. The dealership indicated that the rotors were drenched in blue. The brakes and rotors were replaced. The vibration recurred, the dealership turned the rear rotors and sanded down the rear brakes because the were glazed.

All 4 rotors on my car have gone bad. Car was bought new in oct 2002, and at 8500-9000 miles in March of 03, I had extreme pulsation in steering due to front rotors being warped. Dealer turned rotors, and then 10,000 miles later needed turned again, and now at 33,000 miles dealer is telling me to buy new rotors and that the back rotors also need to be turned. I have been driving for 30 some years and never had a car that needed rotors turned so soon,, and so I am sure there is fault with the rotors they are putting on the car. 2003 Impala.