Four problems related to other fuel system have been reported for the 2003 Chevrolet Silverado. The most recently reported issues are listed below.
Significant corrosion of the fuel (gasoline) lines causing leak and possible safety hazard (fire). Several forums report brake and fuel line premature failure due to corrosion. Gm not addressing this known problem.
This is the second of three fatal collisions investigated this year by my office involving Chevrolet pickups that caught fire after being involved in frontal collisions. This was an off set head on, passenger side to passenger side. Passenger in pickup was pinned in vehicle due to crush and consumed by fire.
While being serviced, my mechanic observed significant rust on fuel lines, transmission and brake lines underneath my truck, as well as in the engine compartment. No recall has been issued. Lines are not leaking as of the date of this report.
On April 19, 2012, the Chevrolet dealership advised me that two or three of my 2003 Chevrolet Silverado diesel fuel injectors, part# 97729095, needed to be replaced and recommended all eight fuel injectors should be replaced at a cost of $5,260,18. I asked if this repair was covered by Chevrolet and the dealer representative said my truck did not qualify because the time limit had expired. He said if the vehicles fuel injectors had failed within the first 200,000 miles or within the first seven years they would have replaced the fuel injectors at no cost. On that date, April 19, 2012 my vehicle had 36,273 miles and was 9 years old, I asked why the dealership hadn't notified me of this problem and they said it was not their responsibility to notify me and refused to replace/repair the defective fuel injectors.