Other Fuel System Tank Assembly problems of the 2005 Dodge Magnum

35 problems related to other fuel system tank assembly have been reported for the 2005 Dodge Magnum. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Dodge Magnum based on all problems reported for the 2005 Magnum.

1 Other Fuel System Tank Assembly problem

Failure Date: 04/01/2020

Tl-the contact owns a 2005 Dodge Magnum. The contact stated that while driving at various speed the vehicle stalls without warning. The contact stated that she would have to fill up fuel tank in oder for the vehicle to not stall. The contact noticed that the fuel seal to the tank was leaking. The vehicle was taken independent mechanic where it was diagnosed that the control valve failed causing fuel to enter the purge line leak and needed to be replaced. The hunter Dodge Chrysler Jeep ram fiat 1130 auto mall dr, lancaster, CA 93534 was contacted however informed the contact that the vehicle would have to be diagnosed at the facility. The vehicle was not repaired. The failure recurred. The manufacturer was made aware of the issue and informed the contact to take the vehicle to the dealer. The failure mileage was approximately 204,000. Ck.

2 Other Fuel System Tank Assembly problem

Failure Date: 07/26/2019

The vehicle stalls multiple times after a fuel fill up. It's very dangerous because it will stall even while driving in traffic. It could cause an accident if other vehicles don't realize my vehicle has stalled. Up to this point I have thankfully not been the cause of an accident. I try to never fill the tank due to this problem. It usually stops once I have driven a few miles and if I open the fuel door to release the built up vapors.

3 Other Fuel System Tank Assembly problem

Failure Date: 06/01/2019

Tl- the contact owns a 2005 Dodge Magnum. The contact stated while driving 65 mph, when the vehicle began to hesitate and then seized. The contact stated no warning light was illuminated. The contact stated he was able to park on the side of the road and restart the ignition but continue to experience the failure. The vehicle was taken to independent mechanic and was informed needing fuel tank to be replaced. The contact called local dealer napleton's northwestern Chrysler Jeep Dodge ram located at 5950 n western Ave, chicago, IL 60659 and were made aware of the failure. The vehicle was not diagnosed or repaired as of yet. The manufacturer had been informed of failure. The failure mileage was 150,000. Dp.

4 Other Fuel System Tank Assembly problem

Failure Date: 04/21/2019

Engine stalls immediately following fuel fill-up. Stalled on highway, difficulty maintaining the car steady. Car now hesitates to start. Can only fill gas tank halfway.

5 Other Fuel System Tank Assembly problem

Failure Date: 12/28/2018

When I fill up gas tank with gas vehicle stalls while drive in traffic on highway and have to be put the gear shift/transmission into park on the roadways to initiate the start up process cause an unsafe/hazardous environment on the road way with other drivers not aware of the issues of the stalled vehicle.

6 Other Fuel System Tank Assembly problem

Failure Date: 09/01/2017

Filled fuel tank up as usual then started the car and immediately the car stalled. I restarted it and it stalled again. Started car again while pressing the gas pedal and it drove a few seconds then a super hard misfire and it cut off again. Finally starts and idles terribly. . . Runs terribly for about 10 miles then it seems to balance itself out. It's been happening consistently for the last few years and almost caused someone to rear end me a few times. I hear there's a recall or lifetime warranty on the fuel tank but no notice was ever sent to me.

7 Other Fuel System Tank Assembly problem

Failure Date: 04/27/2017

When you feel the tank up the car shuts off a couple times until some of the gas went down then it acts normal.

8 Other Fuel System Tank Assembly problem

Failure Date: 02/09/2016

Hello, I need your help and I cannot get any help from Dodge. My vehicle has experienced an issue where the car will stall after the fuel tank is full. I heard that this was an issue but my vehicle was not on the list but however have the same issue. All I want to do is have fairness from an issue that I did not make happen. I have contacted Dodge and they turned me away. Along with the stall engine it almost appear as if it might cause a leak. Can you please help. I will continue to send emails and possible contact corporate office or the mayor. Thank you.

9 Other Fuel System Tank Assembly problem

Failure Date: 12/03/2015

Chrysler is very aware of their fuel tank lifetime warranty for past two years. My vehicle has been sitting in dealership for 10 weeks due to stalling after getting gas in an oncoming intersection. They are not sending the parts and keep giving us the run around. They keep giving us a case manger number that never answers. I guess we are to drive into incoming traffic again and hope for the best. I think its time that this becomes a mandatory recall rather sending out false letters that the problem will be fixed. I am sure we are not the only ones getting the run around or have been almost hit because our cars will not go.

10 Other Fuel System Tank Assembly problem

Failure Date: 12/01/2015

The contact owns a 2005 Dodge Magnum. The contact stated that while driving at approximately 30 mph, the engine stalled without warning. The vehicle did restart. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel tank failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 62,000.

11 Other Fuel System Tank Assembly problem

Failure Date: 11/16/2015

Tl- takata recall. The contact owns a 2005 Dodge Magnum. The contact stated that he noticed a strong odor of fuel fumes and the presence of a leak under the front of the vehicle that progressed with no warning. The vehicle was taken to an independent mechanic for routine maintenance who lifted the vehicle and further inspected that there was a crack in the fuel tank. The mechanic diagnosed that the fuel tank assembly needed to be replaced. The contact was also included in NHTSA campaign numbers: 15v313000 (air bags), 14v770000(air bags) and had not been notified of the safety recalls. The manufacturer was notified of the failure and the contact was also on the status of receiving the recall repairs. The failure mileage was not available. Parts distribution disconnect. Parts distribution disconnect. Djr.

12 Other Fuel System Tank Assembly problem

Failure Date: 09/11/2015

I believe my cars has a problem with the gas tank. On Friday September 11 2015, we drove the car and it had gas at the time, suddenly the car just turned off on the street. On my gas meter or gage is always reading it on empty when it has fuel. It's also smelling like gasoline now. We bought the car from a used car dealer and it's still being financed. How can I know if it's a manufacture problem, I did some research and it happened to say that this gas problem happens to the Dodge Magnum 2005-2006, if it's a manufacture problem do I call the Dodge dealer and will it be fixed by them. I have two children, I can't drive a vehicle that is not safe. What options do I have. The vehicle also has an air bag recall, which the dealer has not fixed because they don't have the parts it's been over 3 weeks since we received the safety recall notice by mail.

13 Other Fuel System Tank Assembly problem

Failure Date: 09/11/2015

The contact owns a 2005 Dodge Magnum. The contact stated that while driving at 35 mph, the vehicle stalled without warning. In addition, the contact stated that the fuel tank gauge increased and decreased independently. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.

14 Other Fuel System Tank Assembly problem

Failure Date: 02/20/2015

I have been having issues with my car just dying while I am driving. It has now happened 4xs. When I went online to research this I came across an extended warranty program from Chrysler which stated this issue was with the gas tank and cars were receiving replacement gas tanks. I called their corporate offices to inquire and was told my VIN was not included. How can a car be excluded when it displays this issue? I am scared to drive. It happened to me on the freeway, in a u-turn, once at a stop light and once just driving down the street.

15 Other Fuel System Tank Assembly problem

Failure Date: 11/15/2014

Purchased a used 2005 Dodge Magnum rt 5. 7 (as is no warranty )on 11/15/14. On the drive home from the dealer, filled the car with fuel and the engine was hard to start and after it started ran for a short time and stalled. After several start stall cycles near the gas station got the car on the interstate and it lost power at speed and ran rough for short periods but did not stall. After aprox. 10 minutes of highway speed the car ran fine. Two weeks later after fill up had the same stalling issues. Having read these cars have history of these issues, I attempted to lower the fuel level by driving the car. The car started and about a 1/2 mile from the house stalled in a busy intersection. Unable to restart the car, had to get towed home. The car started right up when it came off the tow truck. Siphoned 5 gal from fuel tank & can't duplicate failure. No error indications during failures.

16 Other Fuel System Tank Assembly problem

Failure Date: 11/07/2014

Filled up gastank went 5or6 miles car stalled would restart then stall with in a mile ran fine above 30mph cleared up after15-20 miles I understand there is a issue with this just purchased this auto on 11/7 2014.

17 Other Fuel System Tank Assembly problem

Failure Date: 08/22/2014

When the gas tank is filled, the motor cuts out and stalls when driving, I have to keep the tank at half way to avoid this. My wife filled it up and it stalled on her while she was making a left hand turn in traffic. My child was in the car as well. It appears that this organization as well as Chrysler was aware of this situation. I never received any notification and have been dealing with it for some time now. This is unacceptable as my whole family was at stake! please advise the next course of action. I am going to contact my local dealer as a start. Attaching a news article on the situation. .

18 Other Fuel System Tank Assembly problem

Failure Date: 06/04/2014

Immediately after refueling to a full tank engine stalled and almost stopped while at a stop light only about 100 feet from gas satiation. While stopped stumble occurred two times, but never stopped completely. This is clearly a safety issue since a stall could cause traffic problems, brake booster degradation and driver insecurity. This second occurrence in a month.

19 Other Fuel System Tank Assembly problem

Failure Date: 05/09/2014

The car will stall every time after I fill up the gas. It 's very scary because I don't know when the car will die on me when I'm on the road and cars are behind me and just very afraid of someone is going to hit me from behind when my car dies on me suddenly. Yesterday I went to fill up the tank ( not all the way full ), after I drove about 1 block, the car stalled. I was unable to turn the steering wheel and the brakes lost power, I ran off the road and down an embankment to a parking lot right front tire blew out as I hit the curb. Some minor body damage.

20 Other Fuel System Tank Assembly problem

Failure Date: 03/09/2014

The contact owns a 2005 Dodge Magnum. The contact stated that after refueling, the vehicle would idle or stall. The failure was recurring. The contact inspected the vehicle and diagnosed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 109,000.

21 Other Fuel System Tank Assembly problem

Failure Date: 03/03/2014

My 2005 Magnum also exhibits this problem. I would love to get this fixed "Chrysler is extending the fuel-tank warranties on 153,817 2006 Chrysler 300, Dodge charger and Magnum vehicles after complaints of engine stalling at low speeds, according to the national highway traffic safety administration. Nhtsa announced it has ended its probe into the 2006 Chrysler 300, Dodge charger and Magnum vehicles equipped with 5. 7-liter and 6. 1-liter hemi v8 engines. The vehicles were being investigated for fuel vapor recovery system failure following refueling. Nhtsa said there were 299 reports from consumers indicating that the fuel system allowed an overfill condition after refueling and that the engines may stall when the vehicle is stopped or traveling at low speeds. The problem was traced to the multifunction control valve fuel shutoff float in the 19-gallon tanks. The float can swell into a stuck open position, allowing an overfill condition. Chrysler and its supplier, stant, developed new fuel soak test requirements to address the condition and extended the warranty period, according to a Friday posting by NHTSA. The agency oversees vehicle recalls in the u. S. "the condition that is causing the majority of stalling incidents in the subject vehicles occurs at a stop or low speed and allows the vehicle to be restarted immediately," said NHTSA in its summary of the closed investigation. "the condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty. ".

22 Other Fuel System Tank Assembly problem

Failure Date: 02/12/2014

Filled tank and car stall while in the street!.

23 Other Fuel System Tank Assembly problem

Failure Date: 11/24/2013

Filled car with gas. Pulled away from station and car stalled multiple times at stops and low speed turns. No warning, no lights, no sound, no pm, just dead. Restart easy. Stalled about 5 times in 2 miles then behaved. Has happened many times after fill-up now I idle and wait fo short time and hope for the best. Have even shortfill tank before auto click. One scary incident after short fill, car stalled upon entering highway. Stalled causing power stirring issue making it very difficult to pull to side of road. . Car behind followed and almost rear ended my car. Must find fix!.

24 Other Fuel System Tank Assembly problem

Failure Date: 05/22/2013

After fueling up the vehicle to a full tank the car seems to want to stall when coming to a stop. This happened on three separate ocassions within a span of 3 stop lights and when you go to restart the car it doesn't want to start right away leaving you vulnerable at a stop light just sitting there.

25 Other Fuel System Tank Assembly problem

Failure Date: 05/17/2013

Car dies after fill up. They say only fix is to replace fuel tank. I feel Dodge should replace as warranty work because this is a safety issue. . Dodge knows of this problem and if there is an accident because car stalls I feel they are liable.

26 Other Fuel System Tank Assembly problem

Failure Date: 04/08/2013

Upon getting fuel, car would cut out while driving until gas gauge showed about 3/4 full. If manually filled tank to not full, no problem.

27 Other Fuel System Tank Assembly problem

Failure Date: 01/24/2013

I am in the military currently stationed in germany and my 2005 Dodge Magnum had to get a inspection before I can drive. Today when I took it in for the inspection I was told my car was inoperable and will be put in storage until I can get it fixed. The mechanic showed me the tank and on the very bottom it looks like the owner prior to myself had the same issue and tried to seal it with some type of adhesive to fix it. When I purchased my car 2 1/2 years ago the dealer didn't tell me that information so I never knew there was a temporary fix to a serious problem. So now I am forced to pay or a rental car and pay well above the price I would pay in the united states because I have a leak and when I bought the car in 2010 there were only 60,000 miles. Please email me a response at the address listed in section 3 due to time differences and I am not always near my computer to check my skype #. Thank you for your time, hope you can help.

28 Other Fuel System Tank Assembly problem

Failure Date: 08/31/2012

I started smelling gas so bad that the car was not drivable. I had it checked. The top of the gas tank was leaking, which is underneath the back seat where my children sit. It cost about $400. 00 to fix. However, I had to take it back twice because of the "o" rings. (that is what they called it at the place I got my car fixed) they said that the manufature changed the part so they had to of known that there was a problem. They should have recalled it. A gas leak situation, when I have four children in the car could have turned into something more then just a gas leak. The manufature should have made this problem public.

29 Other Fuel System Tank Assembly problem

Failure Date: 03/16/2012

No accident involved, not sure what caused the problem but car stalls when gas tank is filled and pump automatically shuts off. Solution has been to manually pump gas til it get to the full line stop.

30 Other Fuel System Tank Assembly problem

Failure Date: 08/12/2011

Stalls every time you fill up, does not matter how much gas is in the tank, almost allways waits till you pull out into traffic. Stalls 3 or 4 times and then runs fine till next time you fill up.

31 Other Fuel System Tank Assembly problem

Failure Date: 06/01/2011

Car stalls after fueling. This has been going on for several years. The car was bought new and the problem did not start until 2011. Car taken to the dealer several times and they could not find anything wrong because there were no error codes. Back to the dealer in November 2013 and was told at that time that a new fuel tank was needed. The tank replacement was Chrysler's recomendation. The tank was replaced at a cost of almost $2000. 00.

32 Other Fuel System Tank Assembly problem

Failure Date: 09/17/2010

I filled up my gas tank at service station and when I pulled out onto the road, my engine stalled. Very hard to restart. Problem got worse over the years since then, I can no longer fill up my gas tank or the engine will stall every time. I have to keep the tank at 3/4 full or less.

33 Other Fuel System Tank Assembly problem

Failure Date: 09/07/2010

When you fill the gas tank the engine will stall several times until the gas level lowers. If you fill the tank to 3/4 full it wont stall. After the stall the engine will restart after several attempts. Very dangerous if on freeway or no spot to pull over. I bought the car new in 2004.

34 Other Fuel System Tank Assembly problem

Failure Date: 02/09/2010

When the gas tank is filled completely full, the car stalls.

35 Other Fuel System Tank Assembly problem

Failure Date: 05/09/2006

Vehicle stalls after fueling up. It appears to be the same exact problem that has occurred with the x53 fuel tank. This is an extremely hazardous issue that has been going on since the vehicle was new. The hazard is because a stalled vehicle in the road is now an obstruction and an accident waiting to happen. The fact that this issue was diagnosed on the v8 with a 19 gallon tank and was covered by a Chrysler warranty extension admits the issue was on Chrysler and should be extended to these vehicles as well. Service bulletin 14-002-14 and warranty extension bulletin id-14-01 refer to the exact issue as my vehicle.



Fuel Economy of Magnum Vehicles
Magnum Service Bulletins
Magnum Safety Recalls
Magnum Defect Investigations