Body Problems of Dodge Sprinter

The contact owns a 2005 Dodge Sprinter 2500. The contact took the vehicle in for an oil change where it was observed by the technicians that there was excessive corrosion under the hood. The vehicle was taken to the local dealer (huntington beach Chrysler, Dodge, Jeep, ram located on 16701 beach blvd, huntington beach, CA) who informed the contact to reach out to the manufacturer to file a case. The vehicle was not repaired for the corrosion. The manufacturer provided case number: 31763746 and forms for the contact to fill out and submit pictures. The manufacturer stated that they would get back in touch with the contact. The failure mileage was approximately 15,000.

See all problems of the 2005 Dodge Sprinter 🔎.

The contact owns a 2003 Dodge Sprinter 2500. The contact stated that while driving over a bump at an unknown speed, the driver and passenger side sun visors fractured and obstructed the view of the contact. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 160,000.

See all problems of the 2003 Dodge Sprinter 🔎.

The contact owns a 2007 Dodge Sprinter. The contact stated that while attempting to exit the vehicle, the passenger's side rear sliding door closed erroneously, striking the contact abruptly on the head. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 17,000 and the current mileage was 30,000.

See all problems of the 2007 Dodge Sprinter 🔎.

Roof of the Sprinter van is leaking water into the interior. Large sections of the sealing material between panels on the exterior roof has become cracked and is pealing up near the rear of the roof. This allows water to leak into the vehicle causing rust at the seams, and elsewhere?.

My service tech started this van and went back into the house to get his cup of coffee. When he came out of the house he found the van on fire under the hood of the drivers side. The van was towed to tomball Dodge. The fire was determined to have started in the left side head light, causing severe damage to the wiring, hood, fender, bumper, mirror, insulation and much more. Dodge has not taken any responsibility and after 4 months being repaired and at a cost of $12,763. 50. I have four other Sprinters in my fleet, and I am very concerned. I think with the numerous electrical problems that Sprinters have had, this was one that they should have taken care of.

Roof around the roof-mounted air conditioner leaks water after a sustained storm. Has been in dealer service three times, and the leak persists. Others with this vehicle have the same issue. . Read more...

The sliding door which is the only egress for passengers in the back of the van will not open. I have had it fixed 4 times and it continuously fails. I have talked to other Sprinter owners and they have the same problem. Should there be an incident that required the quick evacuation of the van by passengers in the rear of the van they could be very seriously harmed. This is a very serious defect that Chrysler will not acknowledge.

See all problems of the 2004 Dodge Sprinter 🔎.