Structure Problems of Dodge Sprinter

My Sprinter developed a leak in the roof in 2011. Water would collect in the oem roof mounted a/c unit, then leak into the cabin when I started to drive . The quantity of water that would flow through the unit back into the passenger cabin was approx 2-3 cups of water, depended on how much rain water accumulated. I had this repaired in sept 2012 by Mercedes Benz of chicago, for the cost of $1285. This was not under warranty. They said the seal was defective and was allowing water back into the cabin. Most of the cost was for labor, the seal will eventually have to be replaced again, as the roof flexes causing it to eventually crack and break. This is an obvious manufacturing/engineering defect.

See all problems of the 2008 Dodge Sprinter 🔎.

The contact owns a 2007 Dodge Sprinter. While attempting to enter the vehicle the contact noticed that the safety cushion on the center post had fallen off of the post. The vehicle was not diagnosed by the dealer. There were no prior warnings. The current and failure mileages were 14000.

See all problems of the 2007 Dodge Sprinter 🔎.

The contact owns a 2005 Dodge Sprinter. While driving approximately 61 mph, the contact heard a loud rattling noise underneath the vehicle. Upon further inspection, he noticed that the crankshaft harmonic balanced bolt was fractured. The vehicle was towed to the dealer and they stated that the warranty was expired; therefore, the contact would have to replace the bolt at his expense. The contact is in the process of having the vehicle repaired. He has pictures of the failed component. The VIN was unknown. The failure and current mileages were 120,000.

See all problems of the 2005 Dodge Sprinter 🔎.

The roof top air conditioner units are not properly seal and leak rain waiter. This is an on going problem.

2004 Sprinter vans had problems with carbon dioxide getting inside of the vehicle. ** answer required***.

See all problems of the 2004 Dodge Sprinter 🔎.