Five problems related to brake disc rotor have been reported for the 1996 Ford Contour. The most recently reported issues are listed below.
The calipers on the front disk brake system tend to want to roll inward off of the rotors on both sides of the vehicle. This has happened twice to date. Vehicle: 1996 Ford Contour.
The front end of vehicle shakes and rattles when slowing down. . The smell of burning wires are present when ac and heaters are utilized. Very dangerous if you live in cold climate area. Could cause injury or even death during winter months. Ford should do a safety recall on all engine, internal wiring harness, and fix rotors.
The left front axle broke while I was driving the car and it punctured my tire and damaged the rim of it. The mechanic says it was just worn out even though the car is only 3 years old. The check engine light stays on all the time, and there is nothing wrong. The engine rumbles when it idles. The brakes grind all the time, and I have replaced the left rotor 3 times in less than a year. The carpet comes out from under the rear seats an the passenger's side.
Vehicle pulsates when brakes are applied due to warped rotors.
Vehicle has a crack in transmission housing. Consumer states while mechanic was performing routine maintenance he observed a crack in the bottome of the transmission housing, since no transmission work has ever been performed under consumer's ownership roughly since 41,000 miles in the mechanic's opinion that either the transmission housing was cracked when installed or another transmission was put in resulting in a cracked housing, he also observed what might be bad front coil springs, they are making a rubbing nosie on an uneven surface or in a sharp turn to the right,consumer has contacted manufacturer they have called her consumer back but they have turned the complaint into a feedback report consumer has also had rotors turned and serviced twice.