Five problems related to frame and members have been reported for the 2002 Ford Escape. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2002 Ford Escape based on all problems reported for the 2002 Escape.
The contact owns a 2002 Ford Escape. The contact stated that while the vehicle was at the dealer, he was informed that the subframe was severely corroded. The vehicle was repaired under NHTSA campaign number 14v165000 (structure) however, the remedy failed to fix the vehicle. The manufacturer was notified of the failure. The approximate failure mileage was 177,000.
The contact owns a 2002 Ford Escape. While the vehicle was at an independent mechanic for exhaust repairs, the technician noticed that the engine cradle and the lower part of the engine frame were corroded and needed to be replaced. The contact called suburban Ford of sterling heights at (586) 268-7500 (40333 van dyke, sterling heights, mi 48313) and was informed that the VIN was not included in a recall. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 180,000.
The contact owns a 2002 Ford Escape. The contact stated that while driving 30 mph the lower control arm detached from the vehicle and the front passenger side wheel pointed sideways, causing the driver to loose control of the vehicle. The vehicle was towed to the dealer, who stated that the failure was due to corrosion. As a result, the front subframe assembly and the lower control arms needed to be replaced. The manufacturer was made aware of the failure, but offered no assistance because the vehicle was not included in any recalls. The vehicle was not repaired. The failure and current mileages were 78,000.
The contact owns a 2002 Ford Escape. The vehicle was taken to the dealer for routine maintenance where the dealer located severe corrosion at the vehicle under-body, muffler and differential system. The manufacturer was contacted and advised the contact that the vehicle was out of warranty therefore they would not assist with the repair. The vehicle was repaired. The failure and the current mileage was 76,000. Updated 01/06/11. Updated 02/07/11.
The straps which hold up the gas tank on my 2002 Ford Escape are rusted and have snapped in half due to severe corrosion. The front strap is just hanging there. Ford said there is no recall.