Three problems related to electrical system have been reported for the 2004 Ford Excursion. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Ford Excursion based on all problems reported for the 2004 Excursion.
Total loss of engine power massive amount black soot exiting exhaust while driving recall # 05v270000 was not performed on vehicle ( I am the original owner) never received notice in mail and dealer somehow missed this "work" and Ford should have followed through on this situation. Other repairs done to this vehicle to "fix" this problem was to drain the fuel tank (algae in fuel was the excuse-no algae) fuel pump and filter rail (not problem) two turbochargers were replaced due to excessive sooting (one warranty one at my expense) egr valves and a cam sensor (Ford knows the problems exist because Ford discountinued the 6. 0 litre motor) this problem has occured multiple times over my ownership.
Tl the contact owns a 2004 Ford Excursion. While driving, the vehicle stalled without warning. The contact placed the gear into neutral, while in traffic, and restarted the vehicle. Afterwards, the vehicle was able to drive normally. The vehicle was taken to future Ford Lincoln (located at 650 automall dr, roseville, CA 95661, (888) 656-7577) where a wiggle test was performed because a failure code could not be found. The injection control pressure was replaced with a used part. The contact stated that the vehicle was worse after the replacement of the used part and the steering wheel became difficult to steer. The vehicle was taken back to the same dealer who stated that a wire harness was needed to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in NHTSA campaign number: 05v270000 (electrical system). The approximate failure mileage was 59,000.
The contact owns a 2004 Ford Excursion. The contact stated that the entire vehicle is electronic. He stated that the speedometer does not work, the windows occasionally roll up and down, the door locks do not open, and the temperature gauge works intermittently. The vehicle was purchased used and the dealer stated that they cannot repair the failures. The VIN is not included in the recall. The NHTSA campaign id number was unknown. The failure mileage was 90,000.