15 problems related to electrical system have been reported for the 1996 Ford Explorer. The most recently reported issues are listed below.
While driving in "d" in first to second it has had a problem shifting between the 1st and 2nd gears when accelerating and will rev high rpms and sometimes do absolutley nothing when drying to move forward unless I DE accelerate and then try to accelerate agine then finally it will catch and go in to 2nd and proceed to 3rd and then 4th and then 5th ,4th and 5th when accelerating sounds very rough when accelerating like it's trying to hard to drive, lately it just the other day I had trouble getting it to go in to d to 1st 2nd 3rd automatic transmission shifting was not wanting to catch had t ok try 3-6 times DE accelerating and accelerating to try to get it to go finalt it caught and I was able to drive it so I stopped at the parts store had them do a scan and the only code that came up was p1701 they looked it up and it said something to do with trouble in reverse witch in reverse has no problem at all so I'm a little confused about it and also a little scared to drive it when this is my only transportation and if it won't engage in to gear when accelerating when in d that could be potentially dangerous also the odometer and speedometer do not work was told it was vehicle speed sensor so I replaced it still had issue so I replaced the odometer spiral gear hopefully it will fix the problem also the back seat double side would not go down fixed it after pulling it apart and drilling another hole into the spring loaded circle that has a tenchener on it fixed that . . . . And the driver and passenger automatic seats just stopped moving about half way so it's very hard for me to reach the pedal and the automatic side mirrors don't work eather one and the all fuses are good theas are all safety issues that have me concerned since it's all I have so anything or anywhere I can take it or do to it please contact me so it can get fixed ASAP for the shifting issue. Ty.
All four windows intermittently stop working. Cannot go up or down. Doesnt have a preference as to when, happens when the car is off or on.
15 minutes after parking the vehicle and getting off the vehicle caught onfire under the hood in the drivers side. The fire expanded quickly caught drivers side front tire and moved on to the entire motor before the firefighters came and stopped the fire.
Approximately one day after truck was purchased, it was noticed passengers sitting in the back seats of the car could not open their doors. Child safety locks were looked at and reset, but doors still would not open. This is a safety hazard as passengers in the back would not be able to get our safely in the case of an accident.
Approximately one day after truck was purchased from dealer, it was noted that, with the exception of the driver's window, none of the windows in the truck would open. This is a safety hazard as in the event of an accident, passengers in the back seat would not be able to open windows if needed for escape (doors in passenger section of truck did not work either. See previous complaint).
Driver-side front seat belt will not stay connected. Door locks broken (will not lock), and lock key works in the door locks sporadically. In addition, driver-side exterior door handle recently (1/15/2114) will not open door.
1996 Ford Explorer caught fire while driving. Total loss of vehicle within minutes.
The multi-function switch operating the windshield wipers and turn signals fails, resulting in turn signal staying in the on position and results in wire shortage inside the steering column, causing electrical smoke to come out of the steering column. Had I not manually pushed the switch off, there would have been fire within seconds. This has now happened twice in the same vehicle. The switch was replaced the first time, in 2006. That switch also failed, but I was told the part was only under warranty for 12/12, so I cannot have it replaced for free. Since it is faulty, (not caused by the driver) and is a major safety hazard that could lead to injury or death, I believe it is important to raise awareness and get this handled immediately.
On Monday Dec 22 I drove my eddie bauer Explorer to work parked it and went on with my duties at work within 5 min a resident pulls up telling me that my vehicle is on fire . The fire started under the hood and completely burned the whole vehicle I am looking for a any information that would explain this thank you.
1996 Ford Explorer had spontaneous engine fire while parked and unattended. Car had not been driven for 8 hours prior to fire.
1996 eddie bauer, Ford Explorer. . The vehicle has operated fine for the past year, but in June the wipers, windows, interior lights, and some interior systems shut down, then come back on, then lock up again. After talking to my dealer, they tell me it likely the gem going out. They informed me that a recall had been made on 1999 models, but that it didn't cover 1996's. I've spoken to a number of other 1996 owners and have visited a number of Explorer sites online and evidently this isn't an isolated incident. The NHTSA recall for the 1999's is identical to the problems I'm having. . . Is there anything that can be done to correct this problem. The gem is an expensive replacement part and my mechanic says it shouldn't have went out in such a short period of time. The vehicle is mechanically perfect and is kept immaculate, but this problem is making me seriously question purchasing a new vehicle given all the electronic garbage that is placed on them nowadays. Ford doesn't seem to respond to this complaint, just telling me that it isn't a recalled item and therefore isn't their responsibility.
Contact stated in 02-05 the car started smoking while driving. The consumer pulled over and there was a fire under the hood. The car was destroyed. The fire department was called. The consumer reported of having no problems with the cruise control prior to this happening. The consumer was unable to determine what may have caused the fire. He was not sure if it was electrical or caused by the vehicle speed control:cruise control.
While driving interior lights comes on and off without manual operation. Problem occurs within electrial system which causes door locks to malfunction. Please give any further details.
Electrical fire from the interior systems console.
I have a major short somewhere. I have to leave the drivers door open in order to get the car started. If the door is shut it will not idle. This has also happened going down the road and it will just die. (leaving you in a dangerous situation) cannot find anyone to tell us what the problem is. I am wondering if I bought a lemmon.