general problems of the 2021 Ford F-150 - part 1

My husband was driving on the highway with my two daughters in the car when the vehicle stopped driving and he was barely able to pull off the road. It appears to be a defective low-pressure fuel pump. This is an active recall for this model and year, however Ford says that our specific VIN was not involved in the recall. My family could have been killed in this incident!.

Fuel pump failed while driving causing vehicle to be disabled in a roadway blocking traffic. The vehicle was then incapable of shifting to neutral so that it could be moved out of the roadway. A Ford dealer confirmed the faulty fuel pump and replaced the part. Ford appears to know this is a safety issue as per recall campaign 25s75/25v455 but they have refused to pay for the replacement fuel pump.

I own a 2021 Ford F-150, VIN [xxx]. Nhtsa recall 25v455 / Ford recall 25s75 affects my vehicle because of a potential fuel-pump failure that can cause loss of fuel pressure and an engine stall while driving. The recall was issued xxx, and my vehicle still shows an unrepaired recall with the remedy not yet available. I am concerned about the length of time that has passed without a repair being available for a safety-related defect that could cause the engine to stall while driving. I am requesting that NHTSA review the continued delay in providing a remedy. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

We broke down because the fuel pump broke, which has a recall out there. We had stopped at buc-ee’s for a break and when we got back to the truck, it wouldn’t start back up. We got it fixed at banner Ford and were forced to pay $1822. 50 for a fix that a known recall is out for that they claim there’s no remedy for. But, then you’re telling me you can fix it for $1800. It makes no sense that we have to pay for something that there’s a recall for. We are just trying to get our money back.

I've noticed that the vehicle struggle when acceleration, specially at full stop (stoplight and intersection). Feels like the engine is going to die out if I step on gas pedal.

Good morning :) this is my second complaint (1st #xxx) as my truck completely shut down as I was leaving the shop around 4:30pm. As I accelerated it shut down in the middle of the street blocking traffic. I was able to start it again, however it shut down a second time as soon I accelerated. Note: on xxx I did take my truck into Ford for this issue, however nothing could be done as there was no solution yet. (mileage 32899) thank you, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

Truck has just started misfiring out of the blue, have had Ford dealerships look at it, have changed all 6 spark plugs and one ignition coil. The recall NHTSA 2025-366 may be the reason, it states there still is no remedy for this, recall was issued 1 year ago, July 2025. I need this remedy.

On June 20, 2026, my 2021 Ford F-150 5. 0l v8 suddenly lost engine power while I was driving on the freeway. The vehicle became disabled and had to be towed. The vehicle was towed to an authorized Ford dealership on June 23, 2026, where it remains. The dealership inspected the vehicle and confirmed that it is affected by Ford recall 25s75 / NHTSA recall 25v455 and advised that there is currently no available repair or remedy for the fuel pump issue. Ford customer service has also opened a case regarding the vehicle and provided a loaner vehicle, but no repair or estimated date for a remedy has been provided. The sudden loss of engine power while traveling on the freeway created a significant safety hazard. The vehicle could no longer maintain normal speed or acceleration, creating a risk of being struck by other vehicles traveling at highway speeds and a risk to surrounding motorists. Ford's recall identifies this fuel pump issue as capable of causing an engine stall while driving. The vehicle remains at the Ford dealership and is available for inspection upon request. To my knowledge, it has not been inspected by police or an insurance representative. There were no known warning symptoms prior to the failure; the vehicle was operating normally until it suddenly lost engine power on June 20, 2026. The failure is particularly concerning because the recalled component appears to have failed in the exact manner described in the recall, leaving the vehicle disabled while driving. Ford currently has no available remedy, and the vehicle remains unrepaired at the dealership.

My check engine light has been on for a few months, I called sioux falls Ford to ask about it and they told me it's a minimum $200 out of pocket to even look at it. I asked what would happen if the check engine alert had to do with the active recall that is almost a year old that Ford has made no progress to fix, and they said I could file for reimbursement if they deemed the engine warning had to do with the recall. I took my truck to another garage and they found that the check engine light was indeed caused by the fuel pump running at 52psi - the recommended is 51-85psi for my truck. They said the new part would be in the following week to fix it for $1200. When I relayed all of this information to Ford national they told me they weren't able to help me and they were still investigating. They told me that they also weren't responsible for damage to my truck as my powertrain warranty expires next month. They refused to help in any way or offer a timeline of when I could expect a fix. Ford has left me stuck with no options to prevent a potential crash if this faulty piece makes my truck stall on a highway - I can either pay $1200+ for a part from another garage they are legally supposed to fix, or continue to drive a potentially unsafe vehicle based on Ford's negligence. Sioux falls Ford and Ford national, based on a year timeline with several calls and text chats with both, are refusing to comply with their legal responsibility to remedy this safety recall.

This is a continuation/escalation of NHTSA complaint 11689917. My 2021 Ford F-150 has experienced repeated fuel-system/electrical fuel-pump failures. The vehicle previously stalled and later cranked but would not start, returning code p0627 “fuel pump a control circuit / open. ” the in-tank fuel pump was replaced at owner expense for approximately $1,400 at an independent service center in September of 2025, but the repair did not permanently resolve the issue. The vehicle has now again lost fuel pressure/propulsion while traveling approximately 50 mph on a two-lane highway in a similar manner to prior failures. I was able to get the vehicle off the roadway, and it required towing back to my residence. This is approximately the fourth or fifth fuel-related failure, including stalls at low speed and non-start conditions related to fuel in parking lots. The symptoms appear consistent with Ford/NHTSA recall 25v455 / Ford recall 25s75, but my VIN was not included in the affected group. I am concerned that the recall population may be too narrow or that the remedy does not address the full defect pattern.

Brought f150 in for scheduled service - oil change. Also asked for inspection of a problem with the fuel door hatch that was causing "refuel error" messages on the instrument panel and several grinding noises every time the fuel release button was pressed. Note that I have an active extended Ford premiumcare warranty. Dealership diagnosis was that the fuel door solenoid was bad, verified that the gears could be heard grinding with this part. However, there is no separate motor part, therefore the entire fuel door assembly must be replaced. Ford warranty system does not cover this part because it is considered "body and structural". I called Ford protect to discuss this, and explained the motor defect and problem, that this has nothing at all to do with wear & tear or body damage. They explained that in this case, the dealership should call and get the part pre-authorized with the justification. Seelye Ford called and tried to do this on 28 April 2026, but ultimately was still denied by Ford. The attached service report from seelye describes the technician findings and confirms the bad solenoid and audible gear grinding sound coming from the fuel door assembly - and that the entire assembly must be replaced. As this is related to the fuel system and has a defective motor, this is an example a safety defect that should not only be repaired on this vehicle, but for other vehicles with similar problems. Note that the dealership also pointed out that Ford appears to have created this part layout with the intent of having the motor be a separate part, but ultimately did not offer that option, only a full housing replacement, which is excluded because it is mostly made of plastic and metal, which is considered to be structural in nature, despite being a part of the fuel system that has active motor buttons and instrumentation sensors for driver interaction.

While driving my 2021 Ford F-150, the vehicle suddenly began shaking, lost power, and shut off completely while in motion. This created a dangerous situation as I was left without acceleration while driving. Prior to the failure, there were no major issues with the vehicle. After the engine shut off, a battery warning appeared, but the battery had been in good condition and less than a year old. The vehicle would not restart and had to be towed to a Ford dealership, where it has remained for over two weeks. Independent mechanics and the dealership have both indicated the issue is related to the fuel system. I later discovered this matches an active recall for the low-pressure fuel pump. Despite this, I was informed there is currently no remedy available for the recall. The vehicle is still at the dealership and has not been repaired. I have not been provided with a loaner or rental vehicle and have been left without transportation for work or to care for my children. I have also been asked to pay out of pocket for towing and battery replacement, even though the failure appears to be related to a known recall issue.

There is no fix or remedy available for this recalled fuel problem. The recall and fuel pump replacement isn't available and is taking too long. There is hesitation due to this issue.

Several times, the vehicle has failed to accelerate or respond to accellerator pedal input for several seconds. It seems to happen when switching from electric to hybrid modes, and when shifting between lower gears simultaneously. Once the switch to hybrid occurs the engine will rev high with some acceleration even if the accelerator pedal is no longer being pressed. This acceleration has happened when I had my foot over the brake pedal in anticipation of pulling over to stop since the truck would not accelerate. There are no warning lights or messages that appear on the vehicle. It is dangerous because it seems to happen when trying to accelerate from a lower speed. If it happens when trying to change lanes in stop and go traffic or while pulling into traffic other cars would have to brake hard to avoid hitting our vehicle that has experienced stalled acceleration. It is also dangerous because once the transition happens there is brief uncommanded acceleration.

I am reporting a serious safety issue with my 2021 Ford F-150. This truck has already been subject to multiple recalls, yet the problems have continued. On several occasions while driving, the truck has suddenly shut off without warning, causing a complete loss of power while the vehicle is in motion. This has happened while my family and I were in the vehicle and has nearly resulted in a serious crash. Losing power in traffic without warning creates an extremely dangerous situation and has put my family’s lives at risk. A vehicle shutting off while being driven is a major safety hazard. Despite multiple visits for service and ongoing recall issues, the problem has not been resolved, and the truck continues to fail in a way that could easily lead to a catastrophic accident.

The truck’s fuel system can cut out under acceleration. This is very dangerous. Various times it has nearly stalled out under acceleration while trying to merge. The worst time was driving up a bridge, the truck began to hesitate nearly causing a crash. Every time it signals cylinder misfire, but that whole system has been replaced. Very dangerous, very disappointing.

I've been having issues with the vehicle having a lag when accelerating. Upon leaving arizona and traveling to oklahoma I proceeded to pass a vehicle and upon accelerating there was a delay causing a near collision 3 different times. I've contacted the dealership and Ford corporation and they just keep pushing the issue off. 7 months and still no remedy for the fuel pump issue that they have a recall for. Their solution is for me to pay for parts and labor to have a new fuel pump installed which will not fix the problem because it will be the same style of pump that the recall is on and they want me to pay for it.

I own a 2021 Ford F-150 that is part of recall 25s75 for the low?pressure fuel pump. Ford announced this recall years ago, but there is still no fix or parts available. This is a safety issue because the fuel pump can fail and cause the truck to stall or not start. I rely on this vehicle, and it’s frustrating that there is still no remedy after all this time. Many other F-150 owners are reporting the same problem and also cannot get their trucks repaired. I am asking NHTSA to push Ford to release the repair and make parts available.

2021 Ford f150 powerboost hybrid. There is a lot of internet chatter and forum chatter about known issues with the following, and it recently almost led to a major and likely serious injury accident. Specific parameters: low speed (~5 mph) slow roll under internal combustion power, not battery in 2nd gear only when gas pedal is pressed vehicle does nothing. Does not respond. Two choices are to hammer the gas, or hit the breaks. Does two things, slams forward eventually after 3-4 second delay if gas pedal depressed or shifts down or into electric mode (internal combustion off) and then will once again go from first to third in normal acceleration progression and pace they must have an issue with the standard 1-3 skip programming with ice power and 2nd gear being a hang-up I almost got t boned by a semi truck due to this with family in car. This could have been deadly. It happens as an annoyance at least once per day but this one was scary. Online, and based on what I can find - Ford is aware of this issue as they have the 1-3-5 programming in the transmission but when it finds itself (due to real world driving conditions) in 2nd gear under internal combustion, it does not know what to do. I brought it to Ford last year in anchorage and they are attempting to blame it on normal hybrid system operation. That is not the case. It would be something that could be duplicated but with effort. A basic, simple test drive is not going to find this. They are aware of this being an issue. If you have any situation where you are rolling through, merging into traffic, or other scenario where you end up in 2 under ice you are in trouble. Dangerous, scary, and totally a manufacturer issue that is known and needs to be taken very seriously.

Due to waiting for a recall fix for ( NHTSA #-25v455 ) my f150 raptor has been having all listed failing issues, miss fire at idle or when fuel is hot, issue starting on a handful of times. I have been driving it after 4 -5k miles of this and I was alerted today after replacing ( all injectors, coils, spark plugs, etc ) that I may need a new engine. This could have caused a crash and is now costing me an entire engine due to no fix or parts availability. Thousands of dollars for a new engine out of my pocket due to fuel starvation. Cylinder 4 miss fire's at idle. They appeared once I returned home from the mountains back to texas with hot weather.

My vehicle loses power when turning into traffic, when stopping and taking off. There have been several close calls when pulling into traffic as my vehicle will stall out and won't accelerate causing traffic to have to swerve to miss hitting me. I am going to end up getting hit one of these days. Also, it is very dangerous on snow and ice. When trying to accelerate, it cuts out losing power. Keeping my foot on the accelerator, it will eventually get power amd take off unexpectedly and fast. This causes a hazardous issue as well. I have tried to get Ford to buy back the truck or trade for a different one but they refuse to do anything. This is my only transportation and I have to drive it. I am going to end up seriously injured or dying if my truck stalls out in traffic. I can't travel with my grandson because I would be risking his safety. Please make Ford company replace or buy back my truck and full loan pay off.

Recall #25s75 (low pressure fuel pump failure) was issued in July of 2025 and has still not been resolved as of this date (12/23/25). I am filing a formal complaint with NHTSA about Ford motor company not resolving this issue in a timely manner. This appears to be a pattern with fmc regarding recalls, two previous of which took almost a year to remedy.

The truck stalled while driving on back road in the middle of the night we thought it was pout of gas but we still had 100 miles 2nd night same thing but had 250 miles left 3rd day while hearting up in the morning it began to sputter and then quit will not restart now Ford does not seemed concerned nor will offer any help.

Guessing the date below truck shuts off when trying to take off and go. This has happened a few times and even pulling onto a main highway. This is a very dangerous situation, and I have contacted Ford and they have stated there is no fix for this. I have contacted carvana which is where I recently purchased the truck within the past month and they state the recall was listed and there's nothing they can do it's up to Ford to fix a recall. They will not take the truck back and now we are stuck paying for over $30,000 on this truck and it keeps stalling on us. We cannot afford for it to just sit in our yard and pay for it if it's not running. We need help to get this fixed. We have no idea what's causing it but assuming it could have everything to do with the open recall or the battery. That battery is over $4000 if we have to replace it. Another thing we noticed is the led lights on the headlights went out randomly and haven't come back on. Another very expensive fix for a truck we just purchased less than a month ago. We took the truck in the shop within the first few days of owning it due to a few issues we felt were not right like pulling to one side, feeling as if it were going over rutted areas on the roadways with a bump and jerk to it as well like it was a transmission issue. The insurance company with carvana choose the place to take it to and we dropped it off and the next day they called and stated nothing was found to be wrong with it and carvana knew we were out of return in time to replace it when they had us drop it off it was like another day.

Fuel pump went out while driving causing the vehicle to sputtering and so running while driving up a hill. Couldn't restart and stick in park that prevented it from being moved out of roadway. Vehicle had only 64000 miles but wasn't included in recent 2025 recall that covered other vehicles with the dave fuel pump issue.

In July 2025, I received Ford's recall notice stating that is it possible for fuel pressure and flow from the fuel tank to be reduced due to a fuel pump failure- the same condition that caused my breakdown on 11/5/2025 towing the vehicle to the dealer for repair. Because this repair occurred prior to the official recall repair availability, or remedy as is it referred to. The repair cost was deferred to us because there is no official remedy to the recall, and reimbursements are not being entertained until June of 2026.

I started smelling gas in the cabin of the truck when I came to a stop. As I was driving on the freeway I noticed my gas gauge going down rapidly. Within minutes I ran out of gas. Got the truck towed to Ford dealer. After diagnosing the issue I was made aware by Ford service department that one of the high pressure fuel injector cracked and was spraying gas out which caused me to run out of gas. With gas spraying in the engine I was at severe risk of a fire. No warning lights or messages appeared when this happened. After investigating I noticed Ford has a recall for this issue for other vehicles but not the F-150.

Low pressure fuel pump failure yes check engine light is on. Manufacture says there isn't a fix available yet and they have no idea when it will be available. My truck is missing and loosing fuel pressure. This is a 2021 truck and its now 2025. This needs to be fixed or another vehicle if they can't fix , but they have offered no solution.

Vehicle lost all power and stalled while driving. Vehicle also stalled at idle when waiting at an intersection, and another time while waiting at a stop sign. No longer starts. Appears to not be receiving fuel and is returning code p0627 "fuel pump a control circuit / open" and will crank but not start. Required towing back to my residence. Fordpass sent a "service engine soon warning" stating "the powertrain control system has detected an electrical fault with the fuel pump and its associated wiring". The symptoms match those in 25v455 but this VIN number is not listed in the affected group.

4 months after taking vehicle in for recall fixes, both recalls on vehicle have not been remediated due to parts not being available. No eta on availability and get a run around when asking for more info. Hub shaft recall stats that driving the vehicle with a broken hub bolt will wear shafts but no loaner was given so I have no choice but to drive vehicle with a broken bolt. Ford customer service told me its ok to drive the vehicle but never stated if they are replacing the entire rear end or just the parts listed on the recall. . What is dirving the vehicle ruins the splines on the shafts. Are they going to replace those as well?.

I haven't had a issue yet, but I'm not comfortable continuing to drive my truck with a known safety recall that Ford has no solution for even though it's been a recall for several months. I live in a area with no Ford dealerships, so it's a little difficult to get warranty work done.

Fuel pump failed. Ford has stopped sale on the fuel pump because of recall 25s75. I need a fuel pump to operate my vehicle. Ford has offered no solution. It has been 10+ months since my fuel pump failed. Why is there no urgency? what am I supposed to do? Ford doesn't care, you at NHTSA don't care.

I was towing an empty horse trailer on [xxx]. I had left clemson, SC and although I had a half tank, because of my long trip I decided to top the tank off before I left. I had no issues on the drive until suddenly, on a hill, in the middle of a construction zone with barriers on both sides and no shoulders, I lost power, in what felt like the transmission had quit. There was no warning at all, no warning lamps, no messages, no suspicious sounds or behavior. The engine was still running, but very rough. I coasted to a stop and shut if off. I was blocking a lane of traffic, and immediately exited the vehicle through the passenger door because cars were not expecting a stalled vehicle and were narrowly missing hitting my trailer, which had hazard lights on. I ended up blocking a lane of traffic for 3 hours after waiting for the first tow truck which did not show up, and then waiting for another. The vehicle was towed to the nearest dealership. They have diagnosed the failure as the low pressure fuel pump related to recall 25s75. There is no Ford directed action to take in order to resolve the issue. The fuel pump will simply be replaced with another at this point. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

The truck hesitated at a section in the highway where it almost stalled out and I needed to cross over and almost got hit by on coming traffic. Also it has happened multiple times going down the highway the vehicle will start to stop and go it feels like the vehicle is going to stall out. This is very dangerous and I feel like this needs immediate attention.

I have been trying to get a recall situated with Ford now for almost a year. They say they have no fix. I am making payments on truck and can’t use it like I should be. Even came out of my own pocket and had Ford install a new fuel pump however problem came back. Just not fair I purchased a vehicle from a reputable company and they will not help me at all. Not even a loaner.