Body problems of the 2023 Ford F-150

Bolt in the hood latch fell out and nearly causing the hood to open on the interstate.

The sunroof of my vehicle burst while I was driving on the highway. There was no warning and the vehicle was not hit by anything. The glass shattered and came into the truck cabin. Air starting getting in the vehicle as well. It was a dangerous situation as I was driving and glass was coming in. The vehicle was towed to the dealership. The dealership is refusing to repair the vehicle and they can’t confirm why the sunroof broke. The glass is caved outward. I have filed a claim with my insurance company to have the vehicle repaired.

As I was driving the right rear door flung open and would not engage when pulled back in. Had to drive home with a door that would not shut. Yes safety was at risk for kids in back seat. Confirmed by previous reports and service department at dealership. No warning lamps that were noticed.

I closed the passager side door and the back window shattered and blew out.

The rear passenger window rolled down and is stuck in down position. This is the second time this has happened in our F-150. It happened when we first bought the truck nearly two year ago and was fixed. I worry it was replaced with another faulty component. There have been numerous complaints of this happening and the issue is within the driver side door components.

After a repair at ted russel Ford that swapped my battery, the skid plate fell off while traveling in a parking lot. Fortunately this didn’t occur on the interstate.

Water entering cabin on front passenger side of truck. Causing mold and mildew. Dealer 'fixed' this three weeks ago and now it is back again. . .

Bought used at 10k miles less than a year ago, has a severe leak from the passenger side windshield/cowl area that pours down the body seam saturates the floor, wire channel, and bcm area. This is a safety issue as you can smell a burnt/wet wire smell and the incoming water saturates critical wiring, and is nearby airbag wiring. Vehicle in question has only been owned for a year (of 3 year warranty) but any warranty repairs are being refused as it is 4100 miles outside of comprehensive warranty. However, this is not believed to be due to a component that failed due to mileage but rather a manufacturing defect/quality control in the body adhesive not being applied properly near the firewall/cowl/inner fender frame joint.

Bought new a year and a half ago, has a severe leak from the passenger side windshield/cowl area that pours into ac box and then saturates the floor. This is a safety issue as you can smell a burnt/we wire smell and the incoming water saturates critical wiring, and is nearby airbag wiring. Vehicle in question has only been owned for a year and a half (of 3 year warranty) but any warranty repairs are being refused as it is 2500 miles outside of comprehensive warranty. However, this is not believed to be due to a component that failed due to mileage but rather a manufacturing defect/quality control in the windshield or cowl seal.

To whom it may concern, I am writing to formally report a recurring water intrusion issue with my vehicle, which poses a potential safety risk. Whenever it rains and the vehicle is parked outside, water consistently leaks into the passenger-side interior. While driving, especially during acceleration or braking, I can hear the sound of water moving within the passenger side area. Upon inspection, I have found water pooling in the front passenger footwell, where multiple electrical wires are located. Additionally, there is an electrical control box situated beneath the passenger seat that may also be exposed to moisture. I also discovered water leaking behind the rear seat area. This section contains two air vents, which may be contributing to the issue. The water intrusion raises serious concerns about electrical system integrity, especially given the presence of wiring and components in affected areas. Although my vehicle has not yet experienced electrical failure while driving, I am aware of multiple reports from other owners who have encountered similar leaks that led to sudden engine shutdowns, including while driving in traffic — a serious safety hazard. I brought my vehicle to the service center for evaluation, but as of now, I have not received any resolution or updates regarding a fix. I have several videos of the situation as well. Given the potential risk to both vehicle occupants and others on the road, I respectfully request that the NHTSA investigate this matter further to determine whether a recall or other safety action is warranted. Thank you for your attention to this serious issue.

2019 f150 backup camera doesn't work. Ford recalled some 2019 f150's but not mine. I've noticed they are having a huge issue with backup cameras and was also told the same by the dealership. Seems as like they should be responsible for fixing mine too. 2019 supercab door locks freeze. Ford fixed under a recall. The recall worked for a year. Called dealer back last year Ford won't fix it again. It's obviously a manufacturer defect that wasn't fixed correctly on the recall. Seems crazy that I have to pay them to fix it again. The lock freezes open and you can't lock the door. It will open while driving.

Right rear taillight lens has water ingression. The dealer states that they cannot replace the lens under warranty because of a technical issue bulletin issued by Ford moter company that states that condensation is normal and that it should dissipate after a short period of time. Well this has not gone away. And after some time, it will start corroding the electrical connections for the lights and cause them to stop working. The dealer is telling me that it would no be covered under warranty until there is at least a quarter of water in the bottom of the lens. By that time the electrical connections for the lights will be damaged.

During rain and snow events, water leaks into the interior of the vehicle through the roof area. The intrusion appears to occur during moderate to heavy precipitation and results in water collecting inside the cabin. This moisture has led to a persistent, moldy odor throughout the vehicle. The presence of mold poses a health concern, especially for my children and family members who ride in the truck. We are concerned about the potential inhalation of mold-contaminated air and the associated respiratory risks. This issue affects the safe and healthy use of the vehicle and requires attention, as the leak continues to worsen over time. First noticed this issue February of 2024, ongoing.

The sunroof of the vehicle spontaneously shattered. At 65mph glass rained down on myself (driver) and my occupants. Nothing impacted the roof of the vehicle. The sunroof just exploded, causing a loud bang, and prompting me to break quickly. Sharp shards of glass went all over the vehicle focused on the backseat.

There is a leak somewhere in the truck. This leak is causing the carpet to retain and moisture and get caught between the floor mats causing a mildew and moisture smell.

1. Issue number one parking brake engages on and applies the brakes while the vehicle is moving. I had this issue happened to me at least three times; luckily I was not going very fast when it happened. Additionally, parking brake light will come on at random times. (is not auto hold) 2. Multi-functions switch that controls turning signal gets stuck in the up or down position after engaging the switch to change lanes. When attempting to flip the turning signal to off the switch will get stuck and will only go back to off or neutral position after forcing the switch up or down. Additionally, when forcing the turning switch to the off position, it causes the high beams to turn on. 3. Pre-collision assist warning will come on at random times while driving. I have had this happen to me almost daily when I'm driving into work in the morning.

Panoramic sunroof panel exploded while driving the vehicle. The sunroof was closed with shade extended. Less than 2 months new. No debris/ collision or object came in contact with the vehicle. No other vehicles were within either side of the road. The glass panel shattered completely with a very loud explosion noise , raining glass into the truck and onto myself(driver). There were no warning or reason or symptoms prior to the event. I drove the truck to the Ford dealership for a warranty repair after the explosion they ‘inspected’ and reported Ford would not cover this because the glass shattered. Dealer and manufacture are avoiding responsibility for my safety. Truck is at dealer.