Table 1 shows three common gasoline fuel system related problems of the 2017 Ford F-250.
| Problem Category | Number of Problems |
|---|---|
| Fuel Pump problems | |
| Storage Evaporative Emissions Hoses/valves/sensors problems | |
| Gasoline Fuel System problems |
The contact owns a 2017 Ford F-250. The contact stated that while driving at approximately 60 mph, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was towed to the residence. The vehicle was then towed to an unknown local dealer where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The vehicle was towed back to the residence. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the fuel injector and high-pressure fuel pump needed to be replaced. The manufacturer was contacted and referred the contact to the NHTSA hotline. The failure mileage was approximately 139,000.
?the contact owns a 2017 Ford F-250. The contact stated while driving at approximately 40 mph, the vehicle lost automotive power. The contact related the failure with manufacturer campaign number: 21m01. The contact stated that the dense sensor indicated diesel emission fluid was full when it was not. The check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a reductant level sensor failure. The local dealer was contacted; however, the vehicle was not repaired due to costs. The contact stated that the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000.
The contact owns a 2017 Ford F-250. The contact stated that while driving approximately 70 mph in a construction zone, the messages "low fuel pressure" and "reduced power" were displayed, and the vehicle decelerated to 5 mph. The vehicle then lost motive power. The driver was able to veer to the side of the road downhill. The vehicle was towed to the residence. The local dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.