Table 1 shows one common air bag related problems of the 2022 Ford F-250.
| Problem Category | Number of Problems |
|---|---|
| Air Bag problems |
The leather covering on the instrument panel top pad of my 2022 F-250 limited has shrunk and pulled away from its substrate on both the driver and passenger sides. On the passenger side, the covering has contracted enough that it has separated at the seam and lifted at the a-pillar corner, leaving an open gap and exposed backing material. The affected passenger-side panel is the airbag deployment cover; the panel is embossed "airbag" directly on the failed surface. I am concerned that a covering which has shrunk, delaminated from its substrate, and separated at the seam will not tear along its designed deployment path. Ford has previously acknowledged this failure mode in the same component family: NHTSA campaign 22v684000 (Ford 22c23) recalled 2022 f-150 vehicles because an incorrectly manufactured right-side instrument panel cover could break and project fragments into the cabin or allow the airbag to deploy improperly, in noncompliance with fmvss 208. The vehicle was delivered new on 05/16/2022 and is four years old. It has never been in a collision and the dashboard has never been repaired or disturbed. No dressing, protectant, or conditioner of any kind has ever been applied to this panel — it has only ever been cleaned with mild soap and water. The vehicle is garaged or covered roughly half the time, and I have used a windshield sunshade over this panel consistently since delivery. The failed surface is therefore the single most protected surface in the cabin, and it is the one that failed. Nothing about normal driving contacts it. This is a materials or adhesive failure that originated in manufacture. I reported the condition to the selling dealer, sam pack's five star Ford of lewisville, TX. Repair was declined on the basis of elapsed time and mileage. No inspection of the deployment integrity of the panel was performed. I am filing this complaint so the condition is on record and so that NHTSA can determine whether this failure is occurring across the su.
The contact owns a 2022 Ford F-250. The contact stated that while the vehicle was parked, his daughter observed a crack under the Ford emblem where the air bag was located. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 89,072.
I was in a really bad accident nd went off n embankment. My chest hit the steering wheel MD broke my sternum. My seatbelt also didn’t do it port by locking me in place and let me hit forward. Everyone at the scene. Could not believ the airbags didn’t deploy and the seatbelt didn’t help more. I am blessed and very fortunate to be alive!! both doors on passenger side and driver side are hard to open . The damage where the car hit me was in the front.
This vehicle was delivered in July 2022. Shortly after receiving it the steering controls and horn were not always working. I then noticed a clicking sound in the steering wheel. In sept 2022 my local Ford dealer said they replaced the clock spring, but two days to a week after the replacement, the same issue started again. A Ford technician is going to look at this again on Friday 2/3/23.