Table 1 shows one common engine and engine cooling related problems of the 2020 Ford F-550.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems |
The contact owns a 2020 Ford F-550. The contact stated that while driving at 20 mph, the fuel injector became inoperable. The check engine warning light became illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the fuel injectors needed to be replaced. The vehicle was repaired. The manufacturer was contacted and confirmed that the part to repair the vehicle under NHTSA campaign number: 24v957000 (fuel system, diesel) was on back order and that a second notification would be forwarded once parts became available. The failure mileage was approximately 85,172.
At ~93,000 miles, my 2020 Ford F-550 (7. 3l “godzilla” v8) suffered catastrophic engine failure due to a roller lifter bearing failure, causing internal valvetrain damage and requiring full engine replacement. Ford dealer stated they recommended 90% coverage of the repair under goodwill through corporate, but later reduced coverage to 40% without explanation. After repairs, Ford corporate recommended a 3-year/36,000-mile premiumcare warranty, then rescinded it a week later and offered only free oil changes. The 7. 3l engine in my truck shares the same design as the f-53/f-59 motorhome chassis, which have multiple technical service bulletins (tsbs) for lifter bearing failure, overheating of cylinders #2–3, and low oil pressure at idle. My vehicle shows identical symptoms but was excluded from those VIN ranges, suggesting Ford is segmenting related defects to limit recall exposure. Inspection revealed a cracked and arcing spark-plug wire on cylinder #2, matching the motorhome TSB’s overheating issue. This arcing poses a fire risk and likely contributed to localized heat and mechanical failure. The truck was often driven in eco mode, which holds low rpms under load. This can increase cylinder pressure, reduce oil flow, and exacerbate heat in cylinders #2–3—factors that align with the failure pattern. This combination of design-related overheating, lifter bearing failure, oil-pressure fluctuation, and spark-wire arcing presents a clear safety hazard. Engine stall or fire could occur under towing or heavy-load conditions. Nhtsa investigation is warranted into Ford’s 7. 3l godzilla engine design and VIN-exclusion practices.
There was a recall on this veh. Over a year ago and they still do not have the parts to repair it. My fuel milage went from 13. 8 down to 9. 6 and still going down. I have called Ford about this and they say they are still waiting on parts. I reminded them it has been over a year now and should have had the parts in a long time ago.