One problem related to carrier/rack has been reported for the 2004 Ford Freestar. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Ford Freestar based on all problems reported for the 2004 Freestar.
I had my vehicle to the Ford dealership on a recall for the third row latch/corrosion issue. While in the process of doing the repair, the service dept. Found massive undercarriage corrosion, in which other parts of my car were disintegrating & falling apart, such as the starter and the engine mounts, as well as parts of my exhaust system. While my car was on the premises there were also two other Freestars with similar amounts of massive corrosion on the body of the vehicle, particularly all of the doors. My vehicle is only 9 years old and has been taken care of with regular maintenance and should not look 20 years old with the corrosion that it has accumulated. I also have a large, visible crack in my wheel well in the rear passenger area caused by corrosion and my vehicle may not pass inspection. I have been in touch with Ford motor CO. And they seemed only casually interested, but did give me a case file # cas-270-2675-s3d5h6. They report that there is currently no recall on any of the peripheral corrosion problems and could not guarantee that there would be a recall on this. The supervisor at the dealership expressed to me that he has seen at least 6-8 other Freestars with the same corrosion in the same places. My car is rotting from the inside. . . Presently when it rains, my front passenger door accumulates water inside, which eventually drains itself out through the corrosion underneath that panel. Please help me to force a recall on this issue so that I can get my car repaired in an appropriate manner and feel safe in driving without worrying that my vehicle will disintegrate underneath me from this massive corrosion problem.