general problems of the 2016 Ford Fusion - part 2

I was driving my car one day and as I was coming down the road the car jerked and picked up speed like on its on and I had to really stop abruptly to stop the car. I thought that was strange, I didn't have any warning lights or any indication that anything was going on I just thought it was weird, then like 2 days later as was driving the car would do this random jerk but again no lights on any indication anything was wrong so I went to work car seemed fine, got on the high way to go pick up my grand kid after work and when I signaled to change lanes attempted to accelerate to pass, the car just hummed and my speed started to diminish and I immediately coasted to nearest exit because I could not accelerate more than 15 mies, I coasted to a strip mall turned the car off waited til I thought the car settled for a moment and attempted to start the car and when I put the car in gear it jerked but as I tried to accelerate it just hummed and no speed overc15 . So I left the car got it towed the next day to another shop because any Ford dealerships I called to see if I could tow for diagnostic test said they had extensive waiting period like one had weeks before they could look at the car. So I had it towed to another car lot who had a good business rating to be told that it seems to look like something had came loose from the transmission. That I may have to get it replaced, this car starts right up, didn't give me any indication of a problem and doesn't even have a hundred thousand miles on it. Where did Ford drop the ball on this car? im very disappointed , I attempted to drive the car around the corner one day trying to explain to my neighbor the weird behavior of the car and the transmission piece I was told that cane loose, and the car ran fine for about 20 minutes even picking up speed and everything then the moment I got back on my block its like it got warm and then we had to push it back on the driveway it went back to not being able to accelerate. Again.

For over a year my reverse camera is malfunctioning. Initially it seemed like hot days but now its almost all the time it is not working. In October it was recalled and I had my car serviced shortly after and was told they were expecting a resolution to it in December. Still no resolution.

Our 1. 5 ecoboost engine overheated on 3/20/25, my daughter was driving and the vehicle started shaking and it slowed way down, for a moment she feared for her life, she said it had a message and the check engine symbol was illuminated and the vehicle would not accelerate, when she got it was leaking coolant and white smoke, I took my obdii scanner, one code was p1299 cylinder over temp protection active, it now emits white smoke and overheats and looses fluid. Technical service bulletin 1. 5l ecoboost - low coolant, white exhaust smoke and/or illuminated mil - built on or before 10-Jun-2019 20- 2100 01 April 2020 this bulletin supersedes 19-2375. Reason for update: replace awareness/interim message model: Ford 2014-2019 Fusion engine: 1. 5l ecoboost 2017-2019 escape engine: 1. 5l ecoboost summary this article supersedes TSB 19-2375 to update the service procedure and parts list. Issue: some 2014-2019 Fusion vehicles built on or before 10-Jun-2019 and 2017-2019 escape vehicles built on or before 08-Apr-2019 equipped with a 1. 5l ecoboost engine may exhibit low coolant level, white exhaust smoke and/or runs rough condition with or without an illuminated malfunction indicator light (mil) with only diagnostic trouble codes (dtcs) p0300, p0301-p0304, p0316, p0217, p1285 and/or p1299 stored in powertrain control module (pcm). This may be due to coolant intrusion into the cylinder. To resolve the condition, follow the service procedure to replace the short block and head gasket. Action: follow the service procedure steps to correct the condition on vehicles that meet all of the following criteria: • one of the following vehicles: - 2014-2019 Fusion built on or before 10-Jun-2019 - 2017-2019 escape built on or before 08-Apr-2019 • 1. 5l ecoboost engine • at least one of the following conditions: - low coolant level - white exhaust smoke - runs rough condition with or without an illuminated mil with only dtcs p0300, p0301- p0304, p0316, p0217, p1285 and/or p1299 stored in pcm.

Air bag light comes on sometimes not other car panic alarm goes off at random times backup camera sometimes work sometimes glitches.

The backup camera screen is black or dhows a distorted image and sometimes shows an error message like camera not available. This is very dangerous!.

My trunk pops open randomly and will not stay shut.

Backup camera intermittently goes out for a few seconds when backing up, resulting in a blank screen. Putting the driver at risk of property damage or injuring others. I have a small dog & am aftaid of I juring him when backing into driveway. The issue has been recreated by independent service tech but not inspected by any parties. The components/vehicle are available for inspection. There are no warnings or symptoms that I have observed prior to camera cutting out.

Trunk automatically opens while driving numerous times. Pulled over when able and noticed that the actuator clicks continuously until I turned the car off.

Without warning, my car got stuck in reverse while backing out of a parking spot. I could not shift the vehicle into any gear. I was stuck in the middle of a parking lot blocking traffic. Upon inspection, the transmission shifter cable bushing was broken off causing the shifter cable to be dislodged from the actual transmission shifter. Same year, make and model have been recalled but not my VIN.

Purchased a used vehicle. At the time of purchase, there were no visible issues with the car. However, approximately 20 days later, a significant jerking and knocking problem related to the transmission appeared. Due to this issue, I stopped using the vehicle for a while. After consulting with a mechanic, I was informed that the transmission needs to be replaced. As of now, the car is struggling significantly to move. When I turn the ignition, the engine starts, but the vehicle does not move. If I turn the ignition off and restart it, it may move slightly after shaking the vehicle, but then it quickly stops and displays an error again. In this condition, the vehicle is not drivable. Unfortunately, the person I bought the car from refused to accept any responsibility or take the car back, despite my clear communication about the issue. Additionally, the following issues have also started to occur: the steering wheel becomes stiff suddenly. This resolves temporarily after turning the ignition off and on again. The brake pedal sometimes vibrates as if it’s losing pressure. I can clearly feel this under my foot while braking. Sensor malfunctions have also started to appear. The current condition of the vehicle poses serious safety and functionality concerns. Unfortunately, I am not financially able to cover any additional repair costs. Therefore, I would like to know if there is anything legally or technically that can be done regarding this matter. Otherwise, I will be forced to sell this vehicle as scrap. Thank you in advance for your support and assistance. Sincerely,.

Backup camera does not work all the time works only sometimes and sometimes the backup alert does not work right.

I am writing to file a formal complaint regarding my 2016 Ford Fusion hybrid, which I purchased in late June 2024. Despite the ongoing issues with my vehicle, it does not appear on the NHTSA recall list, even though many other Ford owners are experiencing similar problems. Recently, I encountered severe symptoms, including a persistent coolant leak and a puff of white smoke from the tailpipe. Initially, the dealership diagnosed the issue as a simple battery problem related to a cylinder 4 misfire. Following their advice, I spent nearly $500 on a new battery and diagnostic fees. Unfortunately, after driving the car, the engine light reappeared, indicating that the initial diagnosis was insufficient. Upon further inspection, the technician found a puddle of coolant on top of piston 4, which suggests a significant internal problem. This situation mirrors complaints from other Ford owners regarding their ecoboost engines, even though my hybrid engine is not classified as ecoboost. I am concerned about the lack of action regarding these issues, especially since they pose serious safety risks. Additionally, I have been informed by Ford that an engine tear-down is necessary to diagnose the full extent of the problem. If deemed not covered under my warranty, I will be responsible for $1,710 for the tear-down alone, with an estimated cost of around $11,000 for a new engine. As a college student with limited income from a part-time job, I cannot afford these expenses. I urge the NHTSA to investigate this matter and consider the broader implications for all affected Ford vehicles. I look forward to your prompt response. These unresolved issues not only threaten my safety but also potentially endanger others on the road. My repeated attempts to seek support from Ford have been met with inadequate responses, leaving me frustrated and without a clear path forward. I urge the NHTSA to investigate my case and consider a broader review of similar Ford vehicles.

The coolant leaks into the engine, causing misfiring, overheating, and sputtering. The following message is the displayed on the dashboard. "engine coolant over temperature". When this happens, the happens the vehicle barely moves with smoke from the hood. As a result I no longer use the car. I called Ford customer service for remedy and was told that existing recalls are VIN specific and applies to my vehicle. My VIN is [xxx] . Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

The car locked in neutral but the gear shift is locked in park. The bushel broke, which was a recall on my make and model but does not show when I search for recalls on my vehicle.

This is second time my transmission was bad in a Ford.

I was sold this car in 7/2023. I have replaced the transmission 2x now, the flex plate has broken, the brakes have needed replaced 2x. I was sold a lemon vehicle and now the car has a negative equity of $11,000 and I'm completely screwed.

Trunk opening by itself.

Unknown.

The car started to jerk as I was driving. Sometimes it's ok other times it starts when I accelerate like it goes out of gear came on. I did try to take it to autozone with the light had already gone off. I also took it diagnostic. They said that I could transmission control module issue. I change my battery voltage. Immediately battery this resolved the problem for about 30 minutes and then the process started over again. Insecure driving this vehicle at this point I have read online. This is an issue 2016 Ford Fusion I need help .

The abs system light , the traction off and on at the same time, the advanced track light, and finally the tire pressure monitor fault I belive is what it says. The lights came on one day when I crossed over railroad tracks that were a little rough nothing that should damage anything on a vehicle. One after another the lights began coming on. The steering is very tight and makes it hard to drive. When I go over bumps or any uneveness in the roadway the car will shift making the steering wheel jerk and the car to swerve. When you push on the brakes at times it feels like they are skipping and making a weird skipping sound as well. I thought it was needing the brakes so I got all for sides new brakes and rotors. That did not help either. I had a diagnostic scan done the car but it did not pick up anything but an h20 sensor so I got that repaired. I don't know why this is happening and I'm a single mother/grandmother. I cannot afford to spend a lot of money trying to fix these issues.

I was parked in a parking spot in a parking lot and put my car in reverse to back out. As I was backing out my gear shifter cable snapped and I could not put my car back into any other gear. This caused me to be stopped in the middle of the parking lot blocking traffic. If the cable would have snapped before I was in the vehicle it would have rolled back into other vehicles, and possibly a pedestrian. I had to call a tow truck driver who was able to temporarily pop it back into gear to get it in the rollback and tow it to the nearest Ford dealership. It was confirmed at the dealership that it was in fact the gear shifter cable and this was a common problem with Ford Fusions and many had recalls for this exact thing, however my car was not covered under the recall. There were no warning signs of prior issues to this problem and just happened.

When audio system is turned on or volume is turned on, loud cracking booming and static noise comes through at random moments. More noise occurs while driving 55+ but still occurs when idiling. The audio occurrence has almost caused several accidents since its loud ear piercing noises that comes from speakers. I have taken it to the Ford technician to no avail. Due to other forums this is a issue with most Fusions. The noises started occurring after my back up camera was replaced.

Went somewhere in my car. Got out the door wouldn’t latch. Had to drive it home with a broken latch. That in itself is a safety issue! it very well could have broken while I was going down the road at 55mph. I was just lucky it didn’t. I stopped at one mechanic, he said there was a manufacturer recall, the dealership where I got the car won’t honor the recall. They are making me pay $150 diagnostic fee to look at and fix. I’m f course that doesn’t include parts and labor to fix. All that is extra. I may need to take out a loan at the bank to pay for it all.

The driver side door latch will not close. This is apparently a recall being enforced in only certain states. My car was bought, and registered in pennsylvania, and is not covered by the 2 previous recalls for this issue. I do not know why Ford won't cover a door latch repair. The door literally won't close, so the car is not secure and also cannot be driven in this condition. We've tried all methods to get the door to close, none work. Contacted both Ford customer service and our local dealership fred beans Ford in mechanicsburg, PA, and both refused to remedy the complaint.

The component that failed was the flex plate. It is available for inspection at this exact moment, but it’s scheduled to be fixed next week. The safety issue is that it’s intermittently providing adequate power to the engine and causing the vehicles steering to shake violently. The vehicle was inspected by certified Ford dealership and it was proven to reproduce the problem. There were no warning lights on the dashboard and the problem first presented itself 3/07/24.

My back up camera has the same issues that Ford listed in their recall. My screen is black at times when backing up. My camera doesn't always pop up when backing up, my normal screen will stay on as of I'm not backing up. I have had the black screen with a notice that says my camera isn't working and I need to contact my dealership.

I was driving my car when I saw an emergency sign on the dashboard telling to safely park. Then the car could only drive using the power generated by the electric battery and when the battery went out of power the car could not switch to gas to use the engine power I was on san mateo bridge when it happen I could feel the car rolling back on a park gear.

My trunk pops open by itself, without being activated. So far, if I keep my car locked, it will stay shut, but it has popped open while the vehicle was in motion. This is a safety hazard! it has been happening every day for the last several months.

On 23oct2023 I opened the driver's side rear door in my garage. When I went to close the door it would not latch. After several failed attempts I taped the door closed and drove the car to the local Ford dealership for service. The latch mechanism was replaced on 27oct2023. On 01dec2023 I received an email notice from NHTSA regarding a possible recall for the door latches in my vehicle (2016 Ford Fusion), 23v775.

Coolant leak into engine causing over heating 24/7, damaging and leaking into combustion chamber , spark plugs had to be replaced , engine needs another replacement after I had replaced it the first week I got it with the vehicle’s warranty, engine is at risk for engine fire and failure. Transmission shifter cable replacement, became detached and damaged, car was stuck in reverse twice and had to be towed to mechanic . Current recall on breaks because of possible fluid leak for Ford Fusions , at risk for crash. Engine currently is shakey when you first start it up.

The contact owns a 2016 Ford Fusion. The contact stated that while driving at various speeds, the vehicle stalled. The driver was able to restart the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who stated that the failure was due to the throttle. The vehicle was repaired, but the failure recurred. The vehicle was taken to another independent mechanic, who replaced the coil valve, but the failure recurred. The vehicle was taken to the local dealer, where it was diagnosed that the module needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken back to the same local dealer but was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 65,550.

The backup camera has been cutting out recently. Just yesterday, the backup camera is displaying an image that is reversed (object on the sidewalk side (right side) of the vehicle, show up on the street side (left side) of the screen). I can no longer use the backup camera, as it is designed. The dealer has a one-month backlog on appointments, but I am taking it to a non-dealership mechanic on Monday. You will notice in the picture attached, the black car shows up on the left side of the screen, and it's actually on the right side of the car.

My 2016 Fusion hybrid se. All sync related functions ceased to function . Cant use bluetooth. Cant do voice commands. Usb is not working and not charging. Radio works fine, but phone button does nothing; menu button does nothing; voice command button on steering wheel does nothing. This is a safety hazard and I know I'm not the only one having this issue.

The car door won’t latch & the door pops open while I’m driving. There is suppose to be a recall on the door that no one will honor !.

So multiple times in this past year I have been driving my car as normal and when I approach an intersection, decreased my speed, then proceed to accelerate in order to move forward or turn . . . While pressing the accelerator its like I have no power. . It goes into a limp mode. There is nothing that triggers this is behavior. It has occurred multiple times. It has occurred as I have came off the interstate and sat at intersection and also while in city limits. It has happened a handful of times and its not producing any engine light indicators when this is happening. I typically turn off car and then have to turn it back on for it to work again. This is extremely scary for myself and dangerous. I'm concerned about the safety of myself , my family, and other drivers on the road. Failing to accelerate properly at intersection could cause a collision. I've almost been rearended / caused traffic concern & delays attempting to maneuver my car safely off the to the side of road. I've seen multiple comments online about the same issue I took it to Ford garage and they didn't know what it was and say it may be throttle body but their not sure. They were just guessing. I was also told they would try to see if it was covered under warranty but they weren't sure but I never heard back. They told me I could call but I was waiting on them to call. I also spoke to advance auto who said it may be throttle body and/or acceleration pedal sensor. I am financing this car and honestly it has less than 60,000 miles and shouldn't be having these issues.