Three problems related to tank assembly have been reported for the 2000 Ford Ranger. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2000 Ford Ranger based on all problems reported for the 2000 Ranger.
While pulling into my driveway the rear bumper fell off. After getting under the vehicle I found the frame to be rusted from the furthest point back to the axle area. Looking into it more I found the cross member to be rusted to the point that it is ready to fall off. The gas tank holding straps are rusted from the frame, not sure what's holding the gas tank in place. The spare tire holder is rusted and ready to come off. I removed the spare a placed it in the bed for now. The bed and its mounts are shot, the bed can be picked up a good two inches off the frame. Basically the truck is nothing but rust from the cab back. I was lucky when the bumper fell off 1/2 hour earlier I was traveling on a state highway at speeds of 60-65 mph. I have looked at other Rangers the same year and found some worse and some with no rust what so ever. Whats up? and is Ford aware of the problem and are they going to do anything about it. Who would have gotten sued if my bumper had fallen and killed someone?.
Hanger for fuel tank rusted away same as the full size Ford truck just announced in the recall. Currently held up by a nylon strap while searching for parts.
Problems with gauge reading on 2000 Ford Ranger. When the consumer started the vehicle in the morning the gauge would read 20% above full. After driving less than 10 miles the gauge dropped to the true reading 1/4 of a tank. The float in the tank seem to stick causing this problem.