Brake Disc Caliper Problems of Ford Thunderbird

: the contact stated while applying the brake pedal, there was a noise as though the wheel was going to come off. The vehicle was taken to an independent mechanic, who determined the driver side rear caliper, brake shoe and rotor needed to be replaced. Updated 12/12/2006 -.

See all problems of the 2003 Ford Thunderbird 🔎.

Complaint received via e-mail. Front right brake caliper came off and locked up wheel and slid my car sideways when brakes were applied. 2003, Ford, Thunderbird on the day of delivery with 300 miles on the car caliper bolt fell out, and when brakes applied the caliper turned up into the wheel, and jammed wheel. At 6:30 pm. Moved from left to right lane, and applied brakes to slow down approximately 25 mph to turn into a parking lot. Original speed was between 35 and 40 mph. Released brakes, and heard a clung under the car as if we ran over something. Immediately looked back, but saw nothing in the road. Continued to parking lot, applied brakes, and front right wheel locked up, car slid to an angled stop, released brakes ,and rolled forward with very strong clanking noise. We continued into the parking lot. My wife called Ford roadside assistance to repair front right caliper bolts, and wheel was replaced. The proper caliper bolt was not available at the time of replacement. Service used bolt they could find. 1 failure, no one hurt, no police report, just very lucky. The failure caused damage to the vehicle.

Right rear caliper locked up, tearing up the rotor. The left side was also excessively worn as a result of trying to compensate for the right side. Car had a hard time stopping. Dealer had to replace the caliper and rotor on the right rear, as well as both set of brake pads. The left rotor turned because it was warped, but still with in tolerance.

See all problems of the 1997 Ford Thunderbird 🔎.

Brake calipers failed.

See all problems of the 1996 Ford Thunderbird 🔎.

Brake rotor and caliper failed. Mjs.