Eight problems related to steering rack have been reported for the 1999 Ford Windstar. The most recently reported issues are listed below.
The contact owns a 1999 Ford Windstar. The transmission failed while the vehicle was idling at a stop sign. The contact was able to drive home in reverse at 35 mph and the transmission was replaced. The rack and pinion is gradually getting worse and the contact experiences difficulty when turning the vehicle. The dealer stated that fluid was leaking at the boot replacement and the repair would cost $600. The vehicle is currently parked at his residence. The manufacturer stated that the component was not under recall or warranty, so they would not be able to assist. The current mileage was 72,000 and failure mileage was 69,000.
Power steering leaking at steering rack on 1999 Ford Windstar. Approx. 63,000 miles on vehicle. Intial inquiry with mechanic; replacement of rack. Vehicle should not be driven until repaired, loss of power steering at driving speeds can cause loss of control. What is being done regarding this premature failure?.
Sudden loss of power steering. . . 1999 Ford Windstar 68000 mile need driving pump & rack replaced @ $1000. After speaking with number of friends and visiting forums, note that this safety problem appears widespread. Apparent design defect. Ak.
Steering rack failure on 1999 Ford winstar (internal seal failure - 48,182 miles).
1999 Ford Windstar, with 58,000 miles leaks power steering fluid out of left rack. Dealer says common problem with rack and pinion. Makes grinding and squealing sound , constant loss of fluid.
Power steerin rack is leaking fluid. After having to replace the power steering pump ($335+), becuase it burned out due to the failure of the rack, ( leaking fluid through the rack, system couldn't maintain system pressure) I am now faced with having to replace the rack at a cost of over $600.
My 1999 Ford Windstar has suffered a complete steering rack failure with less than 70,000 miles on the vehicle. The service technician informed me the original part was prone to early failure and the replacement component was much improved. However, if there is a flaw in the original part, I feel that Ford should pay for the repair.
The power steering rack is leaking which causes the vehicle to lose power steering while driving.