13 problems related to radiator have been reported for the 1996 GMC Jimmy. The most recently reported issues are listed below.
Radiator sludge/corrosion. Flushed radiator and replaced thermostat. Sludge reappeared and corroded thermostat again. Replaced radiator and over flow tank plus all hoses. Sludge and corrosion reappearing again.
Overheating at 100,00 miles. Open radiator cap to find thick, rusty orange-colored sludge. Replace lower heater hose which had no visible, or detectable hole. Flush radiator, refill w/ dex-cool. Overheats again, mechanic said rusty sludge is clogging radiator. Flush again and refill w/ dex-cool. Still smell antifreeze upon exit of warm car.
Consumer stated corrosion had built up in the cooling system, there was a TSB published concerning a problem with the factory installed antifreeze called dexcool, also the serpentine belt and tensioner were replaced.
Consumer stated corrosion had built up in the cooling system, there was a TSB published concerning a problem with the factory installed antifreeze called dexcool, also the serpentine belt and tensioner were replaced.
Engine check light illuminated on dashboard, and vehicle overheated. Consumer opened radiator cap and noticed thick muddy rusty liquid inside. Consumer has yet to contact a dealer. Please provide any further details.
Radiator went bad and fluid was turning into slush. Contacted dealer, and dealer put texa cooling into radiator, but it made situation worse.
Radiator has been experiencing coolant problems. Coolant used by the dealer was causing sludge. Radiator must be sent out to have it cleaned. Dealer/ manufacturer were not contacted at this time.
Consumer is having problems with the radiator fluid. The radiator fluid is rusting the radiator. Dealer was contacted and stated that there is some type of fluid that is contaminating the radiator. Ph.
Radiator anti freeze torns to a brown sludge that has to be cleaned out of the radiator core at a cost of $335. 00 per cleaning. Based on this defect I am seriourly thinking of purchasing another make of vehicle in 2001.
The dealership had done all the service work since I owned the vehicle,at 47,000 miles the anti-freeze had the consistency of syrup and was clogging up. After much complaining the dealer pulled the radiator had it flushed and refilled. Approx. 30,000 miles later the same thing. They flushed and filled again. It's doing the same thing again in less then a year. They refuse to correct the problem. They informed me I had to pay for it myself. It was never corrected to begin with.
Radiator failed causing leakage due to incorrect installation.
The GMC antifreeze keeps breaking down forming sludge so bad I had to replace the radiator . 6months later it happened again the dealer says that some one put the wrong antifreeze in the system my mechanic says that he has seen antifreeze mixed it it doesn't look like what keeps happening in my cooling system is any one else reporting this problem? my radiator has been repaired by the dealer once replaced by my mechanic once and system flushed. I with in the month had to replace the water pump the dealer did that repair and power flushed the system. It makes me wonder if this isn't a GMC problem like the time they filled the faulty cadilac engine blocks with stop leak to be able to sell them. GMC claims that this anti freeze is supposed to be god for 100000 miles what gives.
Vehicle was overheating because cooling system is not working properly. Dealer indicated rust was in radiator. Contacted dealer.