general problems of the 2017 Hyundai Santa Fe - part 1

After performing regular oil changes, and even a new fuel pump sensor, I experienced an issue. Last oil change was within the past two weeks. Driving home from the mountains, I heard a knocking sound from the engine bay. I narrowed it down to all gears above 2500rpm, increasing knocking with rpm speed. I took it easy on the engine, mostly coasting down the mountain. Suddenly during acceleration on an uphill, a pop sounded, and copious white smoke started coming from the engine bay. I pulled over despite having no power brakes but I was fortunate to be near an off ramp in a rural area. Trying to troubleshoot roadside, I noticed fluid on the tie rod, but I wasnt able to determine what kind of fluid it was. When I try to start the car, there is one single click, the engine wont even attempt to turn over. Oil, battery and check engine lights are all on. After towing, I found that the fluid leaking from the vehicle is oil. The vehicle is currently at a transmission shop, but from my research, this isnt a transmission issue but a blown rod bearing the Hyundai engines are know for. I will be contacting a dealership to see if they will at least confirm my diagnosis.

Bottom brake lights will not work but top high brake light works. I was stopped by police three times. They state all three brake lights must operate.

While driving- in total movement- the car completely shut off. Without any prior warning or indication. Immediately after, the car restarted, drove a couple blocks over, continuing to shut off while driving. It was then towed. How was your safety or the safety of others put at risk? the warning lights did not appear until after the car quit. They all came on & flashed & quickly went back out. Uncertain which component misfired or is affected- possibly related to an engine or fuel/ cylinder failure. Car is at mechanic for inspection. Our safety & lives were in critical jeopardy as the vehicle stopped without warning while driving in traffic congested area. It is unknown if this is a known issue or if this situation has been replicated however the current mechanic facility has experienced the same issue with this vehicle. Also strong odor of gas was experienced during shutoff.

While driving on the highway at normal speed, the vehicle suddenly lost power with no prior warning lamps or messages, placing me and other road users at immediate risk. The engine rapidly began knocking, lost acceleration, then stalled completely. I had to coast to the shoulder, which was extremely dangerous in high-speed traffic. The failure appears consistent with bearing wear and debris circulation described in Hyundai recall 168 and TSB 17-01-071, which warn that certain Hyundai 3. 3l engines can suffer internal metallic debris contamination during manufacturing. This can restrict oil flow, damage the bearings, and lead to sudden engine seizure without warning — exactly what happened in this incident. After the failure, the engine was inspected by a Hyundai dealership, but no oil sample, no debris test, and no photo documentation were provided, even though the recall procedure requires these steps when symptoms match knock/no-start failure patterns. The cause was not reproduced or confirmed by any independent mechanical test; the vehicle simply failed suddenly and has remained inoperable since. The incident created a major safety risk because the sudden loss of power happened at highway speed with no safe way to maintain vehicle control or speed. Based on known recall documentation, the symptoms match the described safety-related engine defect. The vehicle remains available for inspection. There were no injuries or police reports, but the situation definitely could have resulted in a crash. In my assessment, this is a critical safety defect related to internal engine debris and bearing failure, consistent with the known Hyundai recall pattern for this engine family.

I bought this vehicle at enterprise car sales back in March 2nd 2019 and it's been having issues for a while now recall after recall I bought this vehicle at 7745 indiana avenue riverside California 92504 I actually bought this vehicle without realizing that this car had a recall prior to buying it off the lot therefore in California law this company should have not sold the vehicle with a recall as Hyundai has warned me about this as he advised they cannot sell a vehicle with a recall on it. When I had to google search my recall as I have not received a letter enterprise car sales gained the letter for the recall prior to my buy and did not mention anything as this recall was sent out on the letter way prior to buying ever since buying this vehicle I have had numerous recalls as to now there is a gdi issue with the engines as I have made many complaints through the financing company santander consumer USA, Hyundai, enterprise car sales, and it seems like no one has listened to me on the lemon I have gained as I'm sure it sounds just like a complaining customer. I pay a very high interest rate and very high monthly payments 523 a month is expensive let alone expensive to pay for a vehicle that I constantly have to put in maintenance and now my engine is gone my VIN number somehow is not on regards to the recall but yet my VIN number has been on every recall Hyundai has ever given out when it comes to my vehicle as the gdi 3. 3 l should be really considered on regards to a recall as well as the 2. 4. I'm not very happy as I would like to have a voice on to what is fair I am sick of this vehicle having issues after issues as I do take care of my vehicles with good maintenance routine all I can ask for is to have someone here my voice and to take action either from enterprise car sales to Hyundai which I believe enterprise car sales is more reliable at this point than Hyundai since Hyundai let me be aware of the California law they cannot sell a vehicle with recall.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that the automatic power door locks failed to operate as needed. Due to the failure, the contact had to manually unlock and lock all doors inside the vehicle. In addition, the contact stated that the button to unlock the gas cap also failed to operate as needed. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 72,000.

The contact owns a 2017 Hyundai Santa Fe. The contact stated while her husband was driving at approximately 65 mph he heard an abnormal banging sound. The contact stated that her husband said that the sun roof had shattered. The contact stated that her husband had not had highway debris or a stone strike the sun roof. The contact stated that her husband had not noticed any warning lights. Additionally, the contact stated there were multiple electrical failures with the vehicle. The contact stated that the cruise control was not functioning, the tail gate was opening independently. The contact stated that the electrical failures were constant. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there were no electrical failures and were ordering a new sun roof. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 53,000.

While driving, the vehicle lost its brakes and rolled to a stop on [xxx] at that point the vehicle compartment began to fill up with black smoke and soot and flames started to come out of vents. My daughter immediately grabbed her dog and exited from the vehicle to a safe spot away from the car. Within 10 seconds the vehicle exploded and erupted into a 20 ft fireball. If my daughter would have hesitated she could have been killed. Hyundai inspected the vehicle and found nothing conclusive except that this problem has been documented in other incidents. The vehicle was declared to be totaled. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

My complaint is the dealership that said had completed the recall on my brake systems according to both your and state records was not completed. They gave me a service notice stating the work was done. Since then the braked have continued to act up and the vehicle as a strange acceleration problem. The dealership is don wood Hyundai in athens ohio.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that while his wife was driving at undisclosed speeds, the vehicle lost automotive power and the vehicle failed to stop while depressing the brake pedal. The vehicle was allowed to decelerate and come to a stop. No warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the alternator needed to be replaced. The vehicle was repaired. In addition, the contact stated that the engine was previously replaced and the contact was concerned that the warning lights on the instrument panel might not properly display because the check engine warning light had not illuminated during the previous failure. The manufacturer was made aware of the failure. The failure mileage was approximately 121,000.

The liftgate randomly closes and I have to jump out of the way to avoid it hitting me. This obviously poses a huge risk to my young children when they are nearby. In addition to that, the liftgate will sometimes only open a quarter or half of the way, sometimes all the way then suddenly reverse and start closing, and sometimes does not open at all. I've gone on Hyundai forums online and found numerous other people with the exact same complaint. Seems to be effecting cars made from 2016 - 2020. I have multiple videos of this but can't upload them as you only accept pictures.

In June 2024, my vehicle suddenly lost power while I was driving on the freeway, almost causing a serious accident. I managed to restart the car after being stuck on the shoulder of the freeway for several minutes. The same issue occurred the following day, prompting me to have the vehicle towed to the dealership. Hyundai motor was contacted since the vehicle is still under warranty. The dealership informed me they would conduct an oil consumption test three times to diagnose the issue. However, they also stated that for the test to be successful, I needed to replace unrelated parts, including the brakes and transmission oil, among other items. Reluctantly, I agreed and spent $1,800 on these replacements. After completing the first oil consumption test, I returned for the second test. However, the dealership informed me that no further tests were necessary and returned the car to me without addressing the underlying issue. I emailed the case manager assigned by Hyundai to report this, but I never received a response. A few months later, the car failed to start. I contacted Hyundai again, and they dispatched a tow truck. The tow truck driver managed to start the car. A few days later, the issue recurred, and the roadside assistance tow driver suggested it might be the battery. Out of frustration, I paid $300 to replace the battery. Despite this, the car continued to make unusual noises at startup, a problem I had repeatedly mentioned to the dealership and in my communications with Hyundai. The situation reached a critical point today when my wife was driving the vehicle on the freeway with our five children inside. While traveling at 60 miles per hour, the car suddenly lost power again, putting their lives in danger. This is the third time this hazardous issue has occurred, and I fear for the safety of my family.

I bought this vehicle back in 2022 hearing how great Hyundai is wanting to make a long time purchase with a for my family. I’ve had different models vehicles but I wanted something reliable. Now hearing this is possibly a fire hazard I need all this taking care of immediately . I am dependent on my car to get to work, for food, and I take my kids to school an to practice and just everyday life. I will take my vehicle to the dealership immediately to attempt to get this taking care of this week an hopes this company can make it right. Thanks for your time.

Sun roof has opening and closing issues. No warning signs. Could very well cause major issues, broken glass, damage to electrical, interior due to water etc. Called dealership with no luck.

Vehicle has intermittent engine stalling, but is still running. Possible dangerous situation if making left turn with oncoming traffic. This has happened to many times since my owner ship. Bought this car used. I am 2nd owner. 33k mi when purchased in 3-2021.

I had just dropped my son off at the barbershop by my apartment. As I left the parking lot I proceeded to pull out into the street,as I tried to accelerate the car sputtered & lost all power. I then coasted into a nearby wendy's. I parked & tried to crank the car to no avail. I then noticed a burning smell followed by some smoke. I had no dash lights prior to indicate any issues. I ended up calling my insurance to get help with the vehicle. Long story short the starter,coil pack & plugs along with the engine had to be replaced. 2.

My engine failed with regular oil changes at less than 120k miles with no warning. It was 9 at night and it completely shut down on the highway. The hazards, brake lights, etc were not operable! I was almost hit by traffic three times due to not being able to turn on hazards and brake lights not working. I could not even place the car in neutral. Thankfully, the local police department was finally able to assist me but it was a frightening experience and Hyundai is doing absolutely nothing about it.

I believe it is a clock spring failure. The airbag light is on & the buttons on the steering wheel do not work. I searched it & have seen several posts of others having same issue. I really feel this should be looked into, cause this is highly unsafe to be driving around with what very well could be an airbag that doesn't deploy & could seriously hurt drivers.

I was driving on the highway, and suddenly oil and battery light came on and engine stopped and I had to pull over. The only warning was the check engine light came on when I started it 10 minutes before the engine died.

My steering wheel locks up when I am driving and making turns.

My issue - when making turns at night with the low beam headlights on automatic and switching on the left turn signal the headlights go out for up to 30 seconds then come back on. This is very dangerous when driving in rural or low light areas. Possible headlight switch issue. Taken from the internet - I have a 2017 Hyundai tucson and last year this problem only happened once, but now it has been going on for the past 3 consecutive days. If I have my headlights on or on auto and I use the left signal, the headlights turn off. Only the left, not the right. The display on my dash displays the lights going to off and back to auto or on when the signal has been activated and then stopped.

Hyundai safety concerns. The details of the incidents are as follows I own a 2017 Hyundai Santa Fe sport turbo on Saturday June 24th while driving down the palmetto expressway at about 70 mi an hour the vehicle suddenly stopped. It was a very dangerous situation with my family aboard we were lucky to have florida highway patrol toys to a safety location. The car was completely dead and the vehicle was told to homestead Hyundai dealership for repairs 4 days after delivering we received a call letting us know that the computer had been damaged due to a oil leak in the engine that was repaired by them 10 months prior. It has come to our attention that there are recalls for this vehicle for crankshaft problems it is a concern that this is a safety hazard for us and that the dealership is not being transparent with us is the consumer. We have emailed Hyundai motors corporation and filed a complaint. I kindly request your immediate attention to this matter, as the safety of my family and other drivers is at stake. I trust that the national highway traffic safety administration will conduct a thorough examination of the reported incidents, the dealership's actions, and the potential risks associated with the 2017 Hyundai Santa Fe sport turbo. Your intervention and expertise are vital in ensuring consumer safety and holding accountable those responsible for any negligence or lack of transparency. Thank you for your prompt attention to this matter. I eagerly await your response and hope for a swift resolution to this alarming situation.

On June 22, 2023, I went to start my 2017 Hyundai Santa Fe in a shopping center parking lot. I had recently driven from the pgh airport to monroeville and stopped to run errands. Upon reentering my vehicle I used the push button start to start the car. The engine started and the center computer screen turned on, however the dashboard did not light up and I was not able to shift into reverse. I cycled the car ~5 times trying to get it going, but the same start-up happened. Upon calling husband (after trying to start another few times) he recommended that I look at the fuses. At this point I opened the driver side door and was outside looking at the fuse panel. This is when I heard someone shouting from the highway across from the parking lot that my car was on fire. I looked at the rear of my car and saw flames coming from the rear bumper. I quickly stepped away from the vehicle. The entire drivers side of the rear bumper was engulfed in flames. Both the police and fire departments came to the scene. We were collectively able to extinguish the flames and the car was totaled.

The engine seized without warning or notice. No warning lamps came on to indicate anything wrong with the oil pressure, engine, or anything else. I received notices for low gas from time to time, but never anything concerning the engine. I heard engine noises the day before the engine seized. The next day it failed. The car was inspected by the dealership and Hyundai to determine whether the cost would be covered by them and this is what was reported to me in the cost for repair: “engine rebuild/replace: 3. 3l long block, gaskets, and fluids this is the entire process needed to either rebuild or replace the vehicle's engine. This is a process needed when the vehicle's engine is in need of serious repair. ” I was denied coverage because my VIN number was not on the recall list for 2017 Hyundais. I believe it was recall 168. When I looked into it, I read exactly what happened to mine. My safety was a concern because the engine stopped while I was driving and I had to coast into a safe area without causing an accident. I was told by the dealership that this was a common problem for 2017 Hyundai Santa Fe’s but the recall is not for all of the Hyundais this problem has happened to. I was told by a former employee of take5 that Hyundais burn oil quicker than most cars. I can’t confirm that the issue was from a lack of oil, but from what I’ve read, that could be the main issue. I believe a warning on the quickness of oil consumption should be put out as well as an improved warning system/sensors for this make and model.

The contact owns a 2017 Hyundai Santa Fe sport. The contact stated that while driving at various speeds, the vehicle was hesitating while accelerating. Additionally, there was exhaust fumes entering the cabin of the vehicle with white smoke coming from the exhaust pipe. The vehicle was taken to the local dealer, but no failure was found. The contact retrieved the vehicle, but the failure persisted. The vehicle was taken back to the dealer who later diagnosed that the engine had failed and needed to be replaced. No further information was available. The vehicle was not yet repaired. Also, after turning the vehicle off, the radio remained activated causing the battery to drain and the vehicle could not be restarted. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 139,000.

On may 2023, while my husband was taking my daughter to go to school with 2017 Hyundai Santa Fe, he noticed engine knocking noises emanating from the engine compartment. Shortly after, the vehicle's performance significantly deteriorated, and the check engine light illuminated on the dashboard, and the engine shut down. Get the car towed to the nearest auto service, the mechanic told me that there’s an engine failure as result of abnormal oil consumption causing internal damage and need to be fixed by Hyundai. I called Hyundai USA, and was told that in order to have it covered under the warranty, it needed to be repaired by an authorized dealer. However, no authorized dealer had an available appointment for at least 2 months. Finally after 2 months, I had the car towed to the authorized Hyundai service center for diagnosis and repairs. Upon examination by the certified technicians at the Hyundai service center, I was informed that it needs and engine replacement that will cost around $20,000. I called Hyundai corporation and had escalated my case to the case manager, but the manager never called back to give me an update. Their customer service department is also frustrating to deal with. They just sort of repeat the same phrases over and over again rather than having any sort of actual conversation with you. It's been more than 2 months after the incident and they finally they can’t do anything about it because it’s outside of warranty. It’s very frustrating.

Oil pressure sensor failed allowing pressurized oil to leak both externally and also internally into the attached electrical harness. The oil that leaked into the harness traveled to the ecm. The repair shop personnel stated that the failure is not covered by the 10 yr 100,000 mile power train warranty but does possess a fire or electrical failure.

Car began to smoke from engine compartment. Stopped car in a driving lane on interstate 78 where construction barriers had closed both shoulders. Car then burst into flames. Car was a total loss before fire trucks were able to arrive. Just prior to the fire the warning light for the abs system malfunction appeared on the dashboard.

The rear hatch closes automatically even if somebody is under the hatch putting items in the trunk without going back up. This is dangerous especially if children are near the hatch. It also at times opens when the button on the hatch is pushed but does not close automatically. The Hyundai dealership alexandria (1707 mount vernon avenue) was uninterested in the issue and said they would charge $370 to look at the problem. Also for the safety recall of the abs system, the earliest appointment at the same dealership was September 7 even though this sounded like a serious recall.

This will be my second report to the NHTSA. I was originally told my car needed a new engine, but then it was confirmed that was not the issue since the car started and drove just fine, the recall for the abs mod was brought up to two different Hyundai dealerships and their corporate office, I requested if it could not be fixed to buy back my car. It was denied. My car then caught fire while driving, resulting in my husband almost dying on the highway. Fire shot from the bottom of the car up into engulfed flames within seconds…and then blew. Determined it was an electrical engine fire. All could have been avoided if Hyundai had just listened to my concerns and checked my abs. However due their refusal to do so, and refusal to inspect my engine for the recall, my family, kids included were put at risk. It seems to be happening all over the world with these cars and nothing is being done.

Just received another letter from Hyundai (first one in Feb. /March this one in June) telling me about the same problem with the abs system and how it might short out and cause an engine fire. Still no remedy! the letter said I'd receive a second notice . . . I guess they meant a third notice! what's taking so long to find a fix??? I'm supposed to be confident taking this vehicle on a trip knowing it may short out and cause a fire at any time while driving or parked!?? this is not acceptable.

Purchased vehicle 6/2022 has had an electrical problem since day one randomly does not start and must be jumped. I have taken in 2 times only to be told there is nothing wrong. I called Hyundai corporate to see what steps I should take to resolve issues was told to take car in a third time and again told nothing wrong. A new battery was placed two months after my purchase date. And again this past February and issues still exist. Was given two option should problem not be resolved 1) buy back vehicle 2) replace with different vehicle. Both options have been withdrawn. Explanation car has been on the road to long. I put $13500 down and have made payments for 2 years. There is still $12000 on the loan. Is there anything I can do to recoup at least my down-payment. I am a senior on social security and a part time job in which I am a caregiver and do not feel safe driving this vehicle. I and do not have a down payment to trade the car in. I do not want the vehicle there are other issues starting and with a parasitic draw there are bound to be additional issues down the road. Can you help please. Expected resolutionhyundai take car back and return my down payment so I can purchase a reliable vehicle o additionally just recently discovered vehicle was in 2 accidents which this information was never disclosed. I would not have purchased had I known.

I bought this vehicle and there was a complete break down malfunction due to the abs module system! this lack of due diligence caused both myself and my 7 year old to unwillingly enter a vehicle that put our lives at risk and a near death experience that still traumatizes my daughter until this day who refuses to enter any vehicle! this is an unfortunate mistake on your end and there is no where near enough compensation that will ever withdraw the fear from my innocent child’s eyes anytime I need to drive her to school, or basketball practice, or anywhere to run our daily errands and live a normal life! I have nothing else to add except I expect compensation for a safe vehicle and compensation necessary to help my child, my innocent child to get through this fear!.

I purchased my vehicle at 51,700 miles. Approx 2 months …1,000-2,000 miles later my car went into limp mode and wouldn’t exceed 20 mph. I also noticed that my vehicle was consuming 4-qts of oil every 1,000 miles since then and is experiencing engine failure. It’s a safety hazard to myself and others as the car just shuts off completely while driving. Hyundai won’t do anything about it. I have documents to show every oil change/maintenance on vehicle.

My O2 sensor failed and is under my insurance investigation due to engine light that came on and upon inspection it was determined to have caught on fire under the vehicle. My safety and my children's were at risk potentially may have gone up in flames. Currently the insurance is pending review of any recalls for O2 sensor to determine if Hyundai is handling damages. At this time Hyundai has not taken responsibility.