Tank Assembly problems of the 2009 Hyundai Sonata

Three problems related to tank assembly have been reported for the 2009 Hyundai Sonata. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2009 Hyundai Sonata based on all problems reported for the 2009 Sonata.

1 Tank Assembly problem

Failure Date: 11/16/2011

The contact owns a 2009 Hyundai Sonata. The contact was refueling the vehicle when fuel started to escape the filler tank and splash on the contact. The contact did not take the vehicle to the dealer for diagnostics or repairs. The manufacturer was not made aware of the failure. The failure mileage was 92,000.

2 Tank Assembly problem

Failure Date: 02/18/2010

1) was making a right turn into a parking lot. There was a slight incline. There was a quarter of a tank of gas in the car. 2) the engine appeared to turn off, however the electronics never turned off. Power steering was no longer available once the engine stopped running. 3) I attempted to restart the car, but it wouldn't start. You could hear the engine trying to start. I placed the car in neutral and pushed it into a parking space. About 5 minutes later I successfully restarted the car. I had the car towed to the dealership and they could not diagnose the problem or detect that anything had occurred.

3 Tank Assembly problem

Failure Date: 11/12/2009

There has been an odor of gasoline entering the passenger cabin of the vehicle. I noticed it is "worse" when I fill the vehicle with gas but the problem occurs more frequently than that. I do not top off the tank. The pump shuts off when full, and I stop pumping. This odor starts when sitting at a stoplight and stays in the cabin until I'm moving again. I thought it only started when I came to a stop at a light and sat for a couple of minutes, however when I was driving home at slow speeds (15-25 mph) continuous, the smell was constant. Lately it is so bad I have to roll down the window. One time, I almost pulled over at the roadside, and was going to get out of my car to get fresh air, but there was too much traffic. There are no fuel leaks that I can find. No standing fuel under the car after I park. It has done this most times I've driven the car to more or less degrees, but not everytime - most times. I have not been to a dealer yet, but I will be taking it in to have it checked. Apparently there are quite a few other owners of this car who have noticed this same thing based on a Hyundai internet forums. But I did not have this problem until 2010. I can't imagine that this is not a safety issue with the gas odor. Not only are passengers having to inhale these fumes, but I'm wondering if it could be a potential source of fire/explosion. I'm not so sure these are just very few, isolated incidents. I see a problem starting to emerge. Certainly, I will not drive a car that I have to smell gas fumes nearly every time I drive it, not even to mention the profound safety problem this may cause.


Other Gasoline Fuel System related problems of the 2009 Hyundai Sonata

Tank Assembly problems
3
Gasoline Fuel System problems
2


Safety Ratings of Sonata Cars
Fuel Economy of Sonata Vehicles
Sonata Service Bulletins
Sonata Safety Recalls
Sonata Defect Investigations