Table 1 shows one common service brakes related problems of the 2025 Hyundai Tucson.
| Problem Category | Number of Problems |
|---|---|
| Service Brakes problems |
3 incidents of same braking component. Once while exiting a parking lot, the car slams breaks so hard while accelerating that car slams to hard stop with no warning. Once while driving through an intersection brakes engaged for no reason. Once after stopping at red light, then when moving with traffic, car stops so hard with no warning that we were almost rear ended and seat belt left marks and bottom of car seemed to hit the ground. These violent automatic breaking events are scary because for no reason or cause and no warning the car suddenly hard brakes. Fear of being rear ended or car flipping from such sudden and hard breaking. This incident has not been inspected although the car is current on all maintenance and has been recently in to car dealer for oil change.
What component or system failed or malfunctioned, and is it available for inspection upon request? automatic braking system brakes for no reason when I am not near any cars traveling at high speed or even when I am already at a complete stop or moving very slowly but not anywhere near hitting the car in front of me. This has happened multiple times since I leased this car in July 2025 and it seems to be getting worse. I had a 45 min drive home today and it happened about 7 times all for no reason. How was your safety or the safety of others put at risk? it slams on the brakes unnecessarily and the cars behind me almost rear end me. This has happened on residential roads and highways. Has the problem been reproduced or confirmed by a dealer or independent service center? I just called to take it in. They seemed to have no idea what I was talking about. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? not yet but I am taking it in ASAP were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? none.
On at least three occasions, the forward collision system incorrectly determined there was an imminent collision when a car or truck was simply coming over into my lane. The tucscon locked the brakes, bringing the car to a full stop in the middle of high-traffic roads even while the car in front was pulling away. I was unable to give the car gas to continue driving forward. On two occasions this was on an interstate, going from almost 70 mph to stop when there was no car or obstacle in front of the car. It created a very dangerous risk of being rear-ended. The car did display the message "collision warning" on the instrument panel, emit an audible alarm, and shook the steering wheel.
I was on the freeway about 2 minutes and the car flashed a red warning then slammed on the brakes and I flew forward. No cruise control and no buttons hit or anything automatic. Another time, I was merging to freeway on ramp (with 2 lanes merging and going to freeway). I was on the left right lane towards the on ramp and another car came speeding next to me on other the on ramp right lane. All of a sudden, my Tucson says emergency braking for about 1 to 3 seconds. slamps the brakes. I am not sure if the other speeding car made a sensor think I was going to merge into him,or him into me, or the sensors didn't detect the lane markings. It's my daily route to this ramp and it has not occurred in the past. These emergency braking incident has happened several times (4-5 times in a month) to me, usually during a highway drive similar to those above. I have to turn off the forward collsion to stop this happening and it comes back on everytime when the car starts from a off.
I was driving on the highway in heavy traffic going about 65 mph. An unusual symbol appeared on the dash in red that I don't know what it was or what it meant but I thought it must be something serious. Then a warning came up saying for me to take a break. Then a different warning came up saying that I should take control of the car immediately, it was about to brake. The car immediately began to brake. Fortunately I was in the right hand lane of the three-lane highway and I was able to pull into the breakdown lane. I can't even imagine what would have happened if I was in the middle or far left lane. I was not unobservant and both of my hands were on the steering wheel when this happened. Once the vehicle stopped, the symbol on the dash disappeared and the brakes released. I was able to resume driving. Although there was no accident, injury or fire, and no police report needed, this does not discount the seriousness of this event. This could have been life-threatening if I had been in a different lane or had panicked, causing a multi car pileup in the heavy traffic. Serious enough that I feel the need to get rid of this car.
Had an issue with driver assist radar when in complete control. Until you’re not! brakes lock up skidding tires and causing seat belts to lock up. It happens so suddenly it scares you to the point of heart attack. This has happened: merely backing out of driveway, when accelerating in your lane with car in turn lane beside you turning right. And most recently on FL turnpike while in stopped/slowed traffic due to emergency vehicles trying to get to scene of naples wildfire. When I accelerated as traffic resumed at slow speed the car locks up brakes, squalling tires and slewing sideways. It startled me so much my heart was racing and I didn’t know if the car was still running or not. There was an 18 wheeler coming up behind and I was frozen not knowing what to do next. I don’t know if sensitivity can be adjusted or what it needs but my heart can’t take many more of these incidents. I will report to dealer as well. I know there is a reddit thread about these same issues that my daughter found on researching this issue.
Over the past four days, my vehicle has repeatedly applied braking unexpectedly without a valid obstacle or need to brake. This has occurred multiple times under normal driving conditions, including: twice on the freeway in stop-and-go traffic with vehicles at a safe distance ahead multiple times on regular city streets with vehicles ahead at approximately 15–20 feet once while turning into my driveway as my garage door was opening in one instance on the freeway, a vehicle behind me nearly collided due to the sudden unexpected braking. The forward collision-avoidance assist (automatic emergency braking) system is set to “late,” yet the vehicle still applies braking unnecessarily. This behavior did not occur previously and has started happening repeatedly within the past four days. This creates a significant safety risk, particularly in traffic where unexpected braking can cause rear-end collisions. The vehicle has approximately 1050 miles and has not been modified. The issue is currently being evaluated by a Hyundai dealership and has been reported to Hyundai motor America under an open case.
Hello, in my 2025 tuscan hybrid, the vehicle all of a sudden came to a near complete stop driving down the highway at lower speeds due to vehicles in front of me slowing down before a tunnel. While it was apparent I had to slow down, there was no immediate danger to me potentially crashing into the car in front of me which is why I am concerned the car is over reacting to my environment whilst driving.
Vehicle began flashing check driver assistance for rear sensors repeatedly while traveling out of state on March 30th with an occasional flash of check awd/4wd. On March 31st the vehicle flashed the warnings along with a variety of others flashing on the infotainment screen rapidly and shut off while driving. I was barely able to restart to get it safely into a parking lot before it shut down completely without restarting. The vehicle was towed to the Hyundai dealership that it was purchased from. The diagnostics show electrical and safety systems issues. The dealership and Hyundai USA has been less than transparent regarding a repair plan and potential completion date. It is currently April 21st with no end in sight. The vehicle feels completely unsafe to me and I regret the purchase wholeheartedly.
Subject: safety concern – excessive automatic braking (2025 Hyundai Tucson) I am reporting a safety concern regarding the automatic braking system (forward collision-avoidance assist and parking collision-avoidance assist) in my 2025 Hyundai Tucson. The vehicle frequently applies sudden and aggressive braking in situations where there is no immediate collision risk. This occurs during normal driving and low-speed parking scenarios, including when passing nearby objects, backing out of parking spaces, or maneuvering in tight areas. The braking is abrupt enough to create a potential safety hazard, including: - risk of being rear-ended due to unexpected deceleration - disruption of normal traffic flow - reduced driver confidence and control this behavior appears overly sensitive and does not align with actual collision risk in many cases. I have attempted to adjust the system settings (including warning timing), but the issue persists. Additionally, the system resets upon restarting the vehicle, preventing a consistent mitigation of the problem. I am requesting: - a review of this system behavior as a potential safety defect - a software update or calibration option to reduce braking aggressiveness - the ability to permanently adjust or disable this feature please advise on next steps and whether this issue is known or under review. Sincerely, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
Automatic braking engages when there is no actual hazard present and brings vehicle to a full stop. This causes a serious whiplash hazard to me and my passengers as our heads are thrown forward unnecessarily. It also significantly increases the risk of being rear ended by the vehicle behind me. This has happened on several occasions. Today it occurred because the car hit a small bump in the road while doing less than 10 mph. Google search confirms that this is a widespread and well-known defect and that Hyundai has not been willing to release a software upgrade that allows owners to turn-off they automatic braking feature from the dashboard control panel. Immediate action by NHTSA is required before somebody gets seriously injured or killed by this defect.
The automatic braking system has slammed on when traveling at least three times now when there is nothing close by or in front of me. One time a piece of a bag was fluttering on the roadside by me and my t slammed to a full stop almost causing an accident.
I rented this vehicle for 5 days. In those 5 days, twice while driving on the highway (at 5-10 mph under the posted speed limit due to heavy traffic, dry and clear weather), I found it necessary to brake hard due to other vehicle traffic braking hard in front of me. When I had slowed down sufficiently and felt I had sufficient space between my vehicle and the one in front of me, I let off the brake pedal, but the "forward safety" feature continued to brake until the vehicle came to a complete stop nearly causing the vehicle behind me to hit my vehicle. To be clear, no accident occurred, but in one of those instanced the vehicle behind me was within ~1ft of hitting my rear bumper. Had the vehicle behind me not been able to stop in time, there would have been an accident, and because the brakes were locked by the computer, I could not have done anything to prevent it. After the second incident (on 2-15-2026), I looked through the vehicle setup information and found it is possible to disable the "forward safety" feature to prevent additional incidents, however, that setting can only be changed then the vehicle is stationary, and it automatically turns back on every time you start the vehicle.
The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed attempting to park in front of a building, the brake pedal was depressed, however the vehicle failed to stop as intended. The contact stated that the vehicle lunged forward and independently accelerated. No warning lights were illuminated. The vehicle crashed into the building. The crash caused damage to the interior and the exterior of the building. The vehicle was driven to the contact's residence. The vehicle was later taken to a collision center. The contact was informed to bring the vehicle back at a later date. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. No police report was filed. No injuries were sustained. In addition, the contact stated that the vehicle had experienced some electrical issues six months after owning the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 4,500.
Component or system that failed or malfunctioned: the electronic throttle control system and/or the powertrain control system malfunctioned, causing the vehicle to accelerate automatically and involuntarily. How safety was put at risk: the malfunction caused a collision with another vehicle and a structure. The failure placed the safety and physical integrity of two individuals at serious risk. Problem reproduction or confirmation: to my understanding, the issue has not yet been reproduced or confirmed by a dealer or an independent service center. Inspection of the vehicle or component: the vehicle and/or the affected component have not yet been inspected by the manufacturer (Hyundai), law enforcement, or insurance representatives, as an insurance claim is currently in progress. Warning lamps or prior symptoms: there were no warning lights, messages, or other symptoms prior to the failure. The incident occurred suddenly without any prior indication. During the event, the brake pedal did not respond.
The forward collision avoidance system in this generation of Hyundai Tucsons is dangerously flawed. We previously had a 2020 and no issues, but this one slams the brakes at the drop of a hat and has nearly caused several accidents as there is no good reason for the intervention (ample space to leading vehicle) and it brakes so hard that cars behind typically need to veer to avoid rear end collision. This is not a one-off event or linked to particular driver/driving style - both adult owners of this vehicle have experienced this on multiple unrelated occasions. All sensitivity setting have been set to minimum and the only way to drive with peace of mind is to completely disable the system - but here is where the next massive design flaw the system automatically reenables at each re-ignition; there is not permanent override, which is extremely dangerous. It is not practical to manually disable the system on each drive because you need to navigate multiple system menus to adjust the setting. Google and user forums confirm this collision avoidance system is a widely experienced and complained about safety issue for Hyundai and it should be investigated. People will likely get killed due to this “safety feature”. Ideally Hyundai should push a recalibration for those who want this feature and enable a permanent override option in the system settings for those who don’t.
Customer of Hyundai 4 years now. Issues with the forward collison-avoidance assist (fca) on my 2025 tuscan, malfunctioning, aggressively breaking, fantom breaking when absolutely no imminent collision will happen, causing other drivers to come within inches of a rear crash with me, also the same fantom breaking while parallel parking. The breaking causes me to be thrown towards my windshield. Made appointment with a Hyundai service they inspected on a diagnostic machine and no recommended "codes" were available after test was done, no repairs made they said my car is fine. Happened again within 2 blocks of service center please help.
I was travelling east in the left kane on the southern state parkway in long island, NY. The car in fron of me stopped short. I had plenty of time to slow down, then my car brakes locked up and I was almost rearended. Fortunately the driver behind me was alert and moved to the shoulder to avoid contact.
Since taking possession of the vehicle, I have experienced two incidents involving the automatic emergency braking system activating unexpectedly, despite no obstacle or hazard being present. During one of these incidents, the vehicle braked abruptly and forcefully enough to cause an injury to my wrist. On March 7, 2026, I brought the vehicle to the dealership for inspection, where it was confirmed that there is an issue with the front right camera, which appears to be affecting the forward collision and automatic braking system. In addition, the vehicle required premature brake pad replacement due to persistent squeaking. Experiencing brake component issues on a brand-new vehicle raises further concerns about the integrity and reliability of the braking system. Brakes are a critical safety component, and premature wear or abnormal behavior so early in the vehicle’s life undermines confidence in the system designed to protect drivers and surrounding traffic. There were no warning lamps, messages or symptoms prior to the failure. The first instance occurred within 30-days of taking possession of the vehicle. The second two months later.
2 times, while driving 35-40 mph, the vehicle automatically slammed hard on brakes to full stop without any danger or other vehicle near, causing neck pain/whip lash. 3 days ago, I attempted a u-turn in busy intersection, suddenly the vehicle braked hard and came to full stop without any danger near. The dash lights lit up, the vehicle stalled. I was in middle of very busy intersection. It would not move forward. I reversed just in time to miss being slammed into by fast moving oncoming traffic.
While driving a 2025 Hyundai Tucson rental vehicle (VIN: [xxx] ), I experienced a sudden and unintended acceleration, and the steering appeared to turn without input. The vehicle veered off the road and struck a tree on a local street two blocks from my residence. The result was the wheel was popped off of it's axel and deflated immediately. Two days prior, I experienced a similar event in the same vehicle — sudden acceleration and braking hard making a loud braking noise. I suspect a mechanical or electronic malfunction. No warning or sensors were alerting me that this would happen. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
The car breaks itself so abruptly when there is no real danger. This has almost caused for me to be rear ended on multiple occasions. Especially scary on the freeway. The forward collision warning is set to "late," and it still causes a huge jolt.
Approximate date 10/7/2025. Driving 20mph clear daylight sunny conditions in right lane,another vehicle in left lane put on right blinker to merge in front of me into my lane. The merging vehicle was 3 car lengths ahead and had plenty of space to merge. Merging vehicle was only half way into right lane when without touching the brakes and no warning alarm the wheels locked up completely,skidding to a complete stop,almost got rear ended. 2 days later on 10/9/2025 same weather conditions while driving on highway the traffic was stop and go,speed 40mph. A vehicle ahead of me applied their brakes,no imminent threat, I placed my foot on brake pedal as a precaution,then brakes locked up so I pumped brakes thinking what else could I do? this did nothing,brakes remained locked until vehicle stopped. Almost got rear ended again. I can’t remember if any audible alarm or dash warning. These were the only 2 incidents with braking failure. Hyundai dealer booked appointment but they could not find any issues with the braking system on 10/2025. Mechanic could not reproduce braking issue. When I picked up vehicle I spoke to the mechanic. He said “ if the braking issue occurs again please make another appointment. The salesman who I purchased the vehicle said “shut off the warning system”. Which I declined his offer. Thank you!.
While trying to pull out of driveway it will hard stop like im going to hit something. I can be driving thru town and all the sudden it will try to stop abruptley. It does it often. Took to shop and all they would say is all systems work like they are supposed to. My font collision light comes on all the time with some times staying on for a few days. I have tried to wipe it off with no luck keeping it clean. I drove it off the lot turned around asnd they had to replace a head cause it stuck open. Runs funning.
My 2025 Tucson hybrid violently stopped in mid traffic while leaving the intersection once the signal turned green to proceed. I accelerated getting to speed limit then it abruptly stopped, violently throwing contents from back seat to the forward cabin. Both, myself the driver and my passenger were jolted violently. The school bus behind me had to stop quickly as we were just getting up to speed from a stop light. The vehicle is brand new, 2024 miles on it. Tucson nline hybrid with all the safety features turned on. I called the dealer and service rep which both instructed to turn off the fcs forward collision system setting. I did but this shouldn't be happening and will cause bodily harm/damage, and possible death is a specific situation. This abrupt stop was jarring to both people in the car.
My entire dashboard goes black and I lose all directions and functions in car. It happens when driving often. Additionally after taking to dealership, it's getting worse. Now warning lights come on and stay on such as master warning lights, batteries, power steering, etc. Ac shuts off, the car misses out when driving between 25 and 30 mph. The dealership told me it's not safe to drive.
We have had a suspension clunk since we bought this in April 2025. Something is loose in the right rear. They have replace the right and left rear shock mount, the right rear shock and it still persists. There is a clunk or grabbing noise when the brakes are applied as it almost comes to a stop, it appears to be in the front. This has not been found, the last mechanic that looked at this said all new vehicles do this.
I was traveling on [xxx] in nashville. There was a motorcycle speed trap on the right shoulder so I moved over to the left. The car in front of me also moved to the left and my car slammed on the brakes and came to a complete stop on the highway. I was badly rear-ended causing $12,500 in damage. This has happened 2 other times to me since then. This seems to be a consistent problem with the 2025 Hyundai Tucson. I'm fixing my car and selling it as I don't feel safe. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
Automatic brakes are deploying with no apparent hazard.
Several times now the forward collision safety has activated and the car came to an abrupt stop. The car in front of me was braking and I was lightly tapping the brake pedal when out of nowhere the car started shuttering and came to a complete stop. This definitely scared me and I was relieved that the car behind me did not rear end me. I was not going fast by any means and I did not slam on the brakes as there was no need to. The forward collision is not a safety feature. This is a real problem and now I am scared of this braking design. I now deactivate this feature every time I turn the car on because there is no way to permanently dismantle this. Hyundai needs a recall to correct this.
1 forward collision unexpectedly slammed on the brakes when I was trying to go forward to make a left turn. There was no one in front of me nor each side of me. I had 2x4’s in my car that were thrusted forward damaging my dashboard and display. I was told to take it to the dealership on Monday 2 I was fine just hooked up, but the driver was pissed off at me thinking I was stopping short on him 3 randomly the rear sensor would go off telling me they are too close when I’m at a complete stop. It has randomly stopped short on me but I thought it might have just been an over sensitive sensor. I have previously owned an ioniq 5 and the sensor would never stop going off even if I was 2 car lengths away. 4 the car is going back to the dealership on Monday so it has not been expected yet 5 exactly 6 days after purchasing the car the airbag indicator showed up on my dashboard while I was driving. I was used to the ioniq 5 sensors always going on when I was stopped waiting for a green light that I just thought it was the same way. It had abruptly stopped on me three other times between the 6th and today the 21st. I have only had it for 3 weeks. I have never gotten any warnings before the car just slams the breaks on. After looking online about this issue I decided to make a report before I take it to the dealership so you have it on file. I am very disappointed with this vehicle and was so excited when I bought it. I have been a loyal customer of Hyundai since 2017 when I bought my first ioniq and I have purchased 6 other cars for my family members since then. I still purchased the Tucson after having to take a 15,000 loss because the ioniq 5 never held its value. Now I’m wondering if I should switch manufacturers.
On 2 separate occasions, the forward collision warning system activated. On both occasions I was under control of the vehicle with my foot on the brake approaching a vehicle that had slowed while entering into a round about. . . I was approximately 10 feet from the car in front going about 6 mph. All of a sudden several warning indicators activated (audible and visual) and then out of nowhere, all four wheels locked and my car came to a skidding/juddering stop. I immediately looked in rear view mirror fearing I was going to get rear-ended. The vehicle in front proceeded to move on and I tried to get myself together and get moving. I was shocked that this had happened as it was totally unnecessary. I was completely in control of the vehicle prior to the activation.
The 2025 Hyundai Tucson's adaptive cruise control (acc) system does not operate properly due to either a design flaw or a flawed implementation of the design. Hyundai's integration of forward attention warning (faw) with the acc prohibits the driver from using acc while wearing sunglasses. If one is driving the vehicle with acc engaged and puts on sunglasses, the faw flashes a warning on the dashboard and disengages the acc. In order to engage cruise control the driver must interact with the onboard video display system to switch from acc to "dumb cruise". Obviously the driver's attention is distracted while manipulating the selection of cruise control. The driver is also forced to compromise driving safety because they are forced to choose between wearing sunglasses and being able to use acc. Use of acc enhances safety especially when driving into the sun or in low visibility situations. The incompatibility of acc with sunglasses wear then compromises safety. To make matters worse the faw options screen provides erroneous information. It indicates that the driver can turn off faw, but turning it off does not in fact turn it off. Turning it off stops the faw warnings only until the driver turns on and engages acc at which time acc apparently forces faw back on and active. I took the problem to my local Hyundai dealer who confirmed the problem and indicated they could not repair the problem. Since I am considering a georgia lemon law claim, I asked whether I needed to bring the car back since the lemon law gives the dealer/manufacturer 3 tries to fix the problem. The dealer indicated that would be a waste of time because Hyundai will not support/allow the issue to be corrected. The dealer indicated this is a known issue. An internet search also confirms that Hyundai's faw + acc integration is flawed. Additionally it is not clear whether other enhanced vehicle safety systems such as automatic emergency braking are compromised by the wearing of sunglasses?.