Body Problems of Hyundai XG350

Vehicle has a front rusted subframe in two spots on passenger side it will not pass inspection. It is dangerous to keep driving it it looks like there is a recall on this issue in 04/2009, but it says 0 unrepaired recalls which is obviously not correct manufacturer: Hyundai motor company mfr's report date: Apr 14, 2009 NHTSA campaign id number: 09v124000 ea08016 NHTSA action number: ea08016.

See all problems of the 2004 Hyundai XG350 🔎.

There is visible rust/corrosion damage of the front sub- frame of my vehicle. The front subframe has thinned at rusted location. The rusted sub-frame is chewed half of my sub-frame. I am worried that corrosion may progress and may detach from the sub-frame, eventually increasing safety risk. I have noticed steering pull.

Tl the contact owns a 2005 Hyundai Xg350. While the vehicle was undergoing routine maintenance by an independent mechanic, it was discovered that the passenger side frame was rotting away. The mechanic stated that the vehicle should no longer be driven. The manufacturer stated that there were no recalls on the vehicle and nothing could be done. The dealer was not contacted. The failure mileage was 105,000.

See all problems of the 2005 Hyundai XG350 🔎.

Car was parked never had any issues went to crank it uo it just burdt into flames and burned to the ground engine was snoking and snoke coming from underneath and wss oiuring out flames burned up in like 20 minutes or so fire department had to come put it out car is nothing but scrap metal now.

Mechanic tells me that the frame on my Xg350 2005 is very badly rusted and unsafe to drive at 100k miles. All other years of this vehicle have a recall on this issue!! why not the 2005 model? obviously a manufacturer's problem. Many others report the same issue. Also, the air bag warning light is on. I have had this fixed once and it was expensive. Problem is reported many times by other owners.

Tl the contact owns a 2004 Hyundai Xg350. The contact stated that the vehicle experienced abnormal veering and the steering column being loose. The failure occurred without warning. Hall Hyundai newport news located 12872 jefferson Ave newport news, va where it was diagnosed as severe corrosion on the frame. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.

Tl-the contact owns a 2002 Hyundai Xg350. The contact stated that the vehicle was taken to the dealer to be repaired under NHTSA campaign number: 09v124000 (suspension) however, the dealer failed to repair the vehicle. The contact stated that he was given a buyback offer from the manufacturer, but declined the offer. The manufacturer was made aware of the issue. The approximate failure mileage was 160,000. Ah.

See all problems of the 2002 Hyundai XG350 🔎.

I was almost parked at the curb in front of a drugstore with my foot on brake easing into spot when car lurched forward, jumped the curb and violently crashed into the concrete wall about 6-7 feet away. Wall, not brake, stopped car. People came out from store as crash was heard/felt inside. I don't know what would have happened to me if I didn't have seatbelt on. As it was, my chest was extremely sore for several weeks from seatbelt. Airbag didn't deploy. Car was totaled thank god as I would never drive it again. So many complaints with same issue no recalls or service bulletins. Hyundai line is can't find anything wrong when car was checked by them after accident so it is driver error. I've been driving for many years and never had an accident and still consider that I didn't have an accident but not sure of insurance company's stand if I buy another car, if I can find a safe one after all of the recalls. This situation is unacceptable.

I was driving from virginia to new york on route 17 to route 81. I exited to get to a gas station. While turning left from a four-lane road into the gas station, my vehicle made a crashing sound and stopped in the middle of on-coming traffic. It felt like we hit something big. I could not move the car. We had it towed to a garage, where we learned the cv axle had snapped. They also had to replace rs spindle and rs ball joint because they had rusted out. There was cosmetic damage done to body when the axle broke and the car went down hard.

We own an Xg350 Hyundai. Car was brought in to dealer under manufacturer's recall for corrosion of subframe approximately three years ago. Dealer performed manufacturer-suggested repairs: drilled holes in subframe and treated with anti-corrosive. Three years later, subframe completely rotted out and car is a danger to drive. Problem was found when we noticed wheel misalignment (looked like right front wheel was skewed) and that car could not go over even small bumps without sliding across the road. The gentleman who inspected the car for what we thought was going to be an alignment, said that the car was extremely dangerous and in his opinion, was "totaled". We had to have the car towed to the dealership as it is too dangerous to drive the 2 miles. When we called the Hyundai dealer, he agreed to replace the subframe at no cost, admitting that this was a Hyundai problem. I believe that all those people who had the original "fix" are under a false impression that there is no further reason for concern. According to the dealer, the rust is not visible from the outside, which explains why no one saw it 4 months ago when we had snow tires put on. It just suddenly "bursts" from the inside out. He admitted it was dangerous. We are diligent about cleaning the undercarriage of the car every month as we are in a high salt area (massachusetts). We baby the automobile and keep it perfectly. I am angry because my son drives this car and last weekend he was going to take it on the highway for a trip with his friends. If the rust hadn't "burst" through when it did, we would have been unaware of the danger and let him and his friends take the car. This is a death waiting to happen.