general problems of the 2016 Kia Motor Optima - part 1

The kias have been recalled for a failure to adhere the shark fin antenna. This has been recalled in some models. My 2016 has fallen off and is not on the recall list. Please include.

In order to repair the recalled equipment on the vehicle the dealerships and kia want us to pay for them to open the trunk ($280/hour service fee to remove the back seat to gain access to the trunk and then return the back seat once completed). If the trunk latch was not broken to begin with they would not have to remove and replace the back seat of the car at $280/hour you would be able to push the button and open it. I don’t feel it is the car owner responsibility to pay for that access to the trunk.

For a second time, the window goes off the runner and will not operate. This happened to the drivers side window and the rear drivers side window. The only option is to return to the dealership and have the part replaced to allow the window to move up and down, this is a safety hazard and fails state inspection if the windows will not move up and down. This is a safety recall.

Vehicle: 2016 kia Optima lx turbo – approx. 114,155 miles** this complaint concerns ongoing systemic defects affecting the electrical, braking, and engine management systems of the referenced vehicle. Despite multiple documented repair attempts, the failures persist, creating continuous and significant safety hazards. The vehicle has experienced repeated electrical system malfunctions, including multiple battery failures (three replacements within one year), sustained low-voltage conditions, and intermittent lighting loss. Notably, the headlights and exterior lighting have shut off unexpectedly during extended highway operation. The brake control system is also compromised. The electronic emergency brake has engaged spontaneously while the vehicle was in motion, causing abrupt deceleration without driver input. Additionally, the vehicle exhibits continuous fuel vapor and engine performance defects. The purge valve has been replaced four times, yet the failure recurs. The vehicle frequently hesitates upon acceleration, exhibits delayed throttle response, and jerks during takeoff, creating hazardous conditions when merging into traffic or crossing intersections. Given the repeated nature of these defects and the lack of resolution through standard repairs, I believe the vehicle may contain inherent design or manufacturing defects affecting the electrical charging system, ecu, fuel vapor management components, and electronic braking controls. I request that NHTSA conduct an investigation into these safety-related defects.

While driving, the vehicle suddenly developed a loud knocking noise from the engine. Within one block the vehicle began smoking heavily from under the hood. I pulled over, opened the hood, and flames were visible. This is a 2016 kia Optima with the 2. 4l theta ii engine. Approximately one year ago the original engine seized and was replaced by a kia dealer under the theta ii engine recall (sc172/sc147) and class-action settlement. This is the second catastrophic failure of a theta ii engine in this vehicle. The replacement engine has now failed in the exact same manner as the thousands of other documented cases — rod bearing failure leading to knocking, overheating, and engine compartment fire. The dealership (fowler kia of windsor, CO) inspected the vehicle and quoted over $6,000 in repairs (melted engine wiring harness, ecm connector, battery cables, airbox, intake boot, etc. ) while claiming the fire was “unknown cause/not the engine,” despite the clear knocking immediately preceding the fire. Kia consumer affairs has an open case but has not yet resolved coverage. This is a known, ongoing safety defect covered under multiple NHTSA investigations (pe21004, ea22002) and kia recalls. I no longer feel safe in this vehicle and am requesting immediate investigation and inclusion in any expanded recall or remedy.

In 2024 the window regulator went in the drivers side back window costing me $700 and on 9/22/2025 the drivers side front window regulator just went costing me another $700. I see many are having this issue but no recall.

I have a 2016 kia Optima sx turbo with 33,500 miles that the windows one by one are failing due to a defective regulator drum gear. This very flimsy gear fails and the window will not roll up. I have had 3 out of 4 fail in the last month. The only way to keep the window up is to shimmy them. This creates a huge safety risk in the event of an accident and also can impact the collision safety system including airbags. Kia is aware of this situation as outlined in their technical service bulletin dated March 2021. I believe it's bulletin mc-10189544-0011. I've contacted the dealer who doesn't think there is a recall on this issue. This issue creates a safety issue that after only 33,500 miles should not exist.

While driving at approximately 45/50 mph, the right rear window suddenly dropped into the door panel without warning. This unexpected failure startled me and created a distraction while driving, as well as compromised my ability to hear and concentrate safely. My left rear window has also slipped into the door panel and is now being held up by shims and I have now discovered that the issue is due to a failed window regulator. This is a known issue in similar vehicles and poses a potential safety hazard, especially during adverse weather or high-speed driving. The manufacturer has not issued a recall only a bulletin and the cost that was quoted to me from hendrick kia of concord was over $900 dollars a regulator.

I own a 2016 kia Optima ex with VIN [xxx] . The engine failed at 85,763 miles due to a rod bearing seizure. This matches the known defect in kia’s 2. 4l gdi engines, which has been the subject of recalls and service campaigns in the past. Despite being covered under kia’s extended engine warranty, kia America denied my engine replacement claim. They cited "vehicle reconditioning" and "multiple ownership" as reasons — neither of which are valid grounds to void warranty coverage, especially for a known defect. A certified kia dealership (mark kia in scottsdale, az) approved my vehicle for warranty replacement, and submitted the request. Kia corporate denied it. This creates a serious safety concern and shows that kia may be wrongfully avoiding responsibility for this defect. Please investigate. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

A month in after purchasing the check engine light came on. My car did not want to accelerate, started shaking and having jerking movement while driving on the freeway with my newborn and 3 other children in the car with me. Got stranded 3 hours away from home. Car has been in the shop going on 30 days. Spark plugs changed, coolant thermostat changed and now the engine was reported that it has failed. Still in the shop currently.

Have a shake during accelerating 35-40 mph and then again at 70 mph. There is an axle, recall on 2016 kia Optima. For certain months, my is not included. How is the recall determined. Have not had it checked out yet. It seems to be getting worst, will check soon.

The car caught on fire while I was driving. No warning lights came on and the car didn't show it was running hot. I tried to engage the brakes, and they malfunctioned. I coasted the car to the side of the highway, where the fire and smoke plumed from under the car. I immediately exited the car and ran. As I was running from the car the grass was on fire. The car was totally destroyed by fire. The car has not been inspected by my insurance or kia. Kia has a class action settlement for car fires the year, make, and model of mine.

Unknown.

There is a clean slit on my dashboard where the passenger airbags are it’s started to form a complete square around the air bag placement and I’m worried it might have a problem with the airbags and its not just cosmetic. When I googled the issue there are tons of kia drivers with the same clean sit appearing over the passenger air bag. I contacted kia dealership and they said I’d have to pay for a diagnostic fee to determine if it’s a problem but there’s clearly a problem with the 2016 kia so I’m sure all of us owners would appreciate it being recalled.

I have requested that this recall be repaired and updated with the NHTSA, however I've made an appointment, taken this vehicle to the dealership, and called kia corporate, but they have yet to update this repair so that it shows repaired in the system. In addition to this, when I took the vehicle to have the recall fixed, there were other important recalls that I wasn't notified about, this includes the vehicle anti-theft software for this particular model, make, and year and another product improvement as I was also told by another kia associate that this one may be regarding the ecu on this engine.

Driver front side window, passenger front side window, rear driver side window. All windows not going up and down. I had to put door wedges down in the panel to keep windows from falling. I was informed that the regulator and motor in panels that control the switches for movement of windows are burned out. I was also informed from the mechanic this could of been a fire hazard. I was informed from the mechanic. No one around our area had these parts. If I were to purchase them from kia dealership it would cost $1300 to fix all three windows. I don't have that kind of money for repair. Especially when I am not the only person that is dealing with these issues. The list goes on unsatisfied kia Optima owners that is having the same issue with windows.

The windows will not stay up, front passenger window has come completely loose from its track and has fallen down in such away, that it slams against the inside door panel, the only part of the window you can see is the triangle shaped edge that would normally fit in the corner of the window. I'm newly widowed, with kids and this is my only transportation. Winter is here and the only window that stays up is the drivers side, and it's about to go too, it wobbles when rolling it up or down. My dad was a mechanic all his life, but he's 73 with cataracts. I use to help him work on cars every day. . I have a torn rotator cuff from turning my now deceased husband in the month long hospital stay, been with him since I was 17, I'm now 44, and can not do a lot of things I once did. . I do not have the money to fix this car as my husband died 2 months ago being flown in a helicopter twice to the hospital, is more expensive than any vehicle around here costs, I cant work due to my torn rotator cuff. No one in their right mind would buy my car with the windows. . I've done some research and my kia Optima is just one of thousands with this same issue. The only option I have is to walk the 5 miles into town to get what me and what's left of my family's essentials. I've never had a kia before, and I'll never get another one. My car also burns oil, I know this because I was raised to know how to check to see if it's burning oil, I took it into dardanelle tire and auto, I know the lead mechanic. I was informed that infact it was burning oil, and I knew that meant I would have to be checking the oil every other day. The exhaust pipe has so much black burnt oil all over the entire end of the pipe. . Check engine light came on 2 weeks after I bought it, something about the catalyst. The small dealership owner told me everything was perfect on this car, he lied, they have ways of turning the check engine light off, I've seen my dad do it. I think it's time for a recall already.

The window regulators in my 2016 kia Optima have/are failing. The white drum gear that rolls the window up/down shreds and the window falls. My safety is put at risk with this due to the fact that if the window glass were to drop abruptly, it would shatter. To add to the matter, I was out of town this past weekend when another one of my windows failed and had I had not known how to pull the door apart and pull the window back up and tape it, I could have been at major risk of robbery or more. The problem has been reproduced 3/4 times on my car so far. The first time was about a year ago, I repaired the issue myself (costly). Now I have 2 more windows that have failed and I have tape holding them up until I can afford to fix them because kia charges an ungodly amount to repair.

All 4 of the window regulator motors blew in my windows at the same time, only about 9 years into the vehicle's life. The little plastic pulleys that move the cables degrade over time and then ruin the rest of the window motor when they break, and since they decided not to make this an easily repairable part it requires the entire window regulator assembly which is half of the door to be replaced, not just this plastic part. I had to replace all 4 of them out of my own money, kia refused to replace something that is completely 100% their fault and it cost me over $3,500 to repair all four windows that went out pretty much at the same time. It's insane silly that anyone's windows can just break at anytime and be stuck in the down position. I can't just put up trash bags and then not be able to see a thing while I wait to get it fixed if it happens again. I was lucky enough to be in a position to get it looked at quickly, but it is absolutely insane that kia would refuse to cover such a defect. There is already a class-action lawsuit over this I believe but they haven't even attempted to remedy the situation. Not everyone has time to wait for a lawsuit to settle. There should absolutely be some kind of recall/extended warranty on their windows. My engine blew at 57,400 miles only a few months later which is separate and was replaced but it's just insane that I was promised a car but got a piece of trash that consistently breaks while all I can get is a replacement engine with the same exact problem and no confirmation that the same thing won't just happen again while they continue to use the same defective engine over 10 model years. I want them to fix their issues not slap a band-aid over them and hope for the best. This company has been knowingly selling cars built to end up in a landfill within 10 years and they don't care.

My back windows will not roll up and down with the buttons and now whenever I hit a bump and even shut my door, the windows fall down. The only way to get them back up is to physically pull them back up. I cannot get the stay up.

Unknown.

I got on the highway after work, particularly hot day so I had the a/c running. Following nobody, and not next to any cars I hear a loud "crack," followed by yet another loud crack, glass flying to the back of my car, sunroof cover starts rattling back and fourth. I pull over after being jump scared, and come to find my sun roof to be blown upwards.

I brought this car 5/7/2024 and the next day it broke down didn’t start at all I been saying I wanted my money back from day he didn’t take no for answer basically held me hostage until I paid everything. I brought this car and been without a car since this is totally unfair . The clean state motors is a bad service communication place to buy car it was totally the opposite before I gave money for car. Once I gave money they all got mean and had attitudes was saying they was ready to leave instead of giving my money back kept going down finding different prices for car insurance reason why I really brought car I was mentally force and I’m mentally going threw a lot of things because of this . I don’t have no car and the car dealer shop called me and told me I couldn’t get no rental so I can stop calling . I need a new car . A rental . I have missed out on money work and I have 2 kids going on 28 years old this month on 13th these people do not care they took my money and still forcing me to pay 1000 and car note 284 when I haven’t had the car but for one day the next day the car broke down . I am sewing will hear from my lawyer he said I had 30 days to come get my monet back the next morning I called for my money back they said no this unfair I turn in all information paid insurance 795 which is to high I just need my money back I didn’t even get to keep car a week literally next day car did not start he never said car was being brought as is if so I would have not brought it and I didn’t sign all those papers delewin had to forfeit my signature this was fraud scam to me I need a car the engine broke down car batter was linking and white acid was everywhere inside front car and I wasn’t suppose to look at that car is was a white kia 2019 this not right this unfair please help me on fixing this I deserve a car.

The front and rear windows come down unexpectedly. The power controls do not control the windows. This is especially dangerous when younger children are riding in the car and can reach their hands out the windows because the windows just come down. I have to manually lift my windows up.

Snow white pearl paint is flying off of my car in big splotches.

As of today all 4 of my power windows have failed. The first was in Feb, 2 in Aug (50k miles) and the last one today. Looking at the failed parts it matches kia TSB#300.

Earlier this week, I went to the grocery store and noticed that the antenna cover had fallen off my car during the drive. Nothing unusual had happened on the way. In fact, the only thing unusual over the last few weeks was some rather cold temperatures for georgia. I did look up recalls and saw that there was a recall for this item for kia Optimas from 2016, but a service technician said that the recall did not include my vehicle. Is it possible that the recall is not inclusive of all vehicles with a problem? this is a surprisingly expensive repair for me otherwise. Thanks for your consideration and I appreciate any guidance you can give me.

My 2016 Optima started burning a quart of oil at 60000 miles I am now burning over 1 quart of oil every 1000 miles. I took it to the dealership where I bought it from and was they would change my oil to do an oil consumption test and I was to drive it no more than 1000 miles. I brought up my warranty for engine replacement and was told yes I do have warranty. I drove it just under 1000 miles took it back, was told I was burning oil but I would need to do an engine flush 1st, for the cost of $600. I told the young women that was not what she said. I have been dealing with this issue since 2021. I don’t know if you can help me or not , if not can you give me any advice thank you (I am not sure of the exact dates that it started).

All four windows are not operational and ceased function. All 4 of the windows are currently propped up. I spoke to kia dealership and they are familiar with the problem they are having alot of complaints with this issue. They can repair all 4 windows for a cost of $2000. 00 +. I really don’t have the money for this. I got pulled over by the cops and was so scared because I couldn’t roll my windows down. This is very unsafe. I’m in a very difficult situation. Kia vehicles are defective and dangerous because the power window regulators fail and cause the windows to fail. There is currently a class action lawsuit against kia for this issue, [xxx] et al. V. Kia America inc. , case no. [xxx] filed in California. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

We were backing up of out a parking spot at the local 7 eleven and another car almost cream us till the associate that was outside at the moment yelled out a warning.

Purchased this car in July of this year. I checked all fluids prior to purchase and after driving it for 30 days the oil light flicked then went off. I decided to check the oil and it was 2 quarts low. I immediately called my extended warranty and they said to take it to the shop. After it being there for 3 months they said it was the rings in the piston and it needed a new motor. They referred to it as excessive oil consumption. Of course the warranty company old republic refused to cover it because it’s a on going issue with this model car.

I got this recall done. I found out about it because my insurance raised a couple hundred dollars a month and when I called they told me about this recall. I got the recall done however, when the insurance pulls up my VIN # they state it is still flagged. I contacted nys dmv about this and they stated the information is supposed to be sent to you (NHTSA). When I put in my VIN number in the window prior it came up with the safety issue and said 0 recalls. So, does that mean that it was sent in that the car has this? I was on the phone today with kia for almost an hour and they could not advise me on anything pertaining to this. I would appreciate if you can let me know if the document was sent/processed because the insurance company is stating my VIN number is still flagged. Thank you for any help you provide me. I am using this form because when I clicked on email I do not have the email app installed and could not find a regular email address. My email is : melindaaa@urgentmail. Com.

All four windows stopped working within two months of each other. The motors still work, but the plastics parts inside broke. The trunk latch also stopped working and the trunk won’t stay shut. There are recalls on the 2016 Optima for the trunk latch, but the dealer says my VIN isn’t involved. There are also tech notices for the windows on the 2016 kia Optima, but no recalls yet. There is a class action lawsuit for the windows also for safety reasons. No one would be able to get out of the windows or trunk if the car were in an accident because none of them work. Kia is useless to fix their junky cars. The mileage is 70,000.

My daughter was driving on the interstate and her car lost power while driving. This is a major safety issue. A car losing power in the middle of 80 or higher mph traffic could result in fatalities.

I had all four of my window regulators to go out within two days of each other and now my windows constantly drop automatically while driving especially if I go over speed bumps, hit pot holes or any type of bump. I try to keep them up by placing paper or holders in them but they only hold up for so long and at times when I’m driving they drop down and I’m afraid the glass will break completely because one of them dropped while driving and the window cracked. This is a very dangerous situation and kia tried to charge me when I went to them and I know this has to be a defect for all windows to go out.