Two problems related to brake disc caliper have been reported for the 2004 Kia Motor Sedona. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Kia Motor Sedona based on all problems reported for the 2004 Sedona.
This van has brake problems squeaking and wearing out pads way too fast. I was told nothing is wrong with the brake system but when taking it to a brake shop I was told the calipers are bad, kia has not fixed them and denies that they're bad. The check engine light came on and I was told that a spark plug had misfired, that was fixed under warranty and then another spark plug misfired and was fixed under warranty. The oil level was getting low but I had no leak and I was told that the oil filter was simply loose so they said they fixed it. I asked if I should bring the van back in a week to have the oil level checked and we were assured there was no leak. Check engine light came on again and the oil light flickered, did not stay illuminated, so we took it to the dealership immediately, as the owners manual and the mechanic had stated. Then we're told that there's sludge in the engine and that it will be 2,000 dollars to take it apart and check the damage that we caused from continuing to drive it. They never told us there was any reason to not drive it nor did they mention sludge previously. The van will be towed back to kia tomorrow.
: the contact stated at various speeds, the vehicle's front brakes made a screeching noise. The vehicle was taken to the dealership who determined that the front brake pads were worn and installed new pads. The vehicle returned to the dealer 4 months later, because the pads wore out prematurely and had to be replaced. This did not remedy the problem. On the 3rd visit, the dealer replaced the front calipers but the problem persisted. The vehicle was taken to the dealer on 2 other occasions for front pad replacement, but the problem persisted. The manufacturer was not contacted.