Table 1 shows one common electrical system related problems of the 2025 Kia Motor Sorento.
| Problem Category | Number of Problems |
|---|---|
| Electrical System problems |
The contact owns a 2025 kia Sorento. The contact stated that an unknown, sticky fluid had spilled through the slits of the mode selector which was a dial that can be selected for driving during different road conditions. Upon start of the vehicle, the 4wd mode selector would intermittently flash on the instrument panel. In addition, the contact stated the mode selector would remain stuck in eco drive and that the contact could not switch out of the mode selector. The vehicle was taken to a dealer where upon a diagnostic, it was discovered that an unknown, sticky substance had entered the mode selector through the slits in the mode selector. The contact agreed to have the part replaced; however, the part for the repair was on backorder. The manufacturer was notified of the failure where they refused to offer any assistance with the vehicle's repair. The vehicle remained in the dealer's possession and had yet to be repaired. The failure mileage was approximately 8,000.
I purchased this vehicle from mcgrath kia in [xxx] . The fuel line recall kept me from picking up the car the day of purchase as was indented and stated. This was deception because they knew about the recall even know they waited for me to sign the contract before telling me. This was verified by another sales person at kia. The current problem is electrical with the 12 volt battery discharging to zero at unusual and times with no particular reason such as lights or anything in the vehicle turned in the on position or running. The service coordinator told me the solution is to un hook the battery terminal when stopped. That is wildly unacceptable to have myself and family risk injury due to kia's faulty electronics on a newly manufactured vehicle. This added risk of using the kia Sorento makes it unsafe. Multiple visits to the dealership resulted in nothing. They did not want me to bring the car in twice as they don't have a solution. This is becoming more frequent and the mcgrath is openly stating I'm over 12 months time for lemon law and ill have to pay to fix my new car. Which has the "lifetime" warranty. Im stuck with a new car that's unsafe to drive. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
The contact owns a 2025 kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled. There was no warning light illuminated. The contact stated that the braking system became inoperable and failed to function properly. Additionally, while the vehicle was parked, it failed to start and lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed that the electrical system had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. The vehicle was then taken to another dealer, where it was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 22,000.
I have a 2025 kia Sorento hybrid and several months a go car play stoped working correctly if car developers like to replace the car stereo with car play or a new tecnology they better make shore that the tecnology is working correctly before they install it in people vehicle don't let the consumer develop the product for tham, car play is not working, at times sounds stop playing ,navigation stop talking and there is no ai I'm a uber driver wen I"m in the car I need to concentrate on the road driving I should not trying to figure out how to fix the sound, or what is wrong with car play. I would like for apple to make a recall. Car play is a very dangers issue that no one is been able to fix. Please I hope you take this in cosideration it's a sefty issue. Mahalo.
I am submitting this revised complaint to correct a prior report that was not accurately documented during a phone submission. Vehicle: 2025 kia Sorento (259 miles at purchase) within approximately two months of ownership (~3,000 miles), the vehicle began experiencing serious safety-related issues, including intermittent stalling, braking problems, and electrical malfunctions. Symptoms include: •vehicle stalled and failed to restart, leaving me stranded •radio/display screen went blank •heating/climate system became nonfunctional •vehicle would not shift into neutral •persistent burning odor inside and outside the vehicle these issues raise concern about a potential fire risk. In may 2025, the vehicle was inspected by two separate dealerships, both of which reported no issues. The condition worsened, resulting in a complete failure requiring towing. A dealership later identified “electrical issues,” but key symptoms were not documented. A second dealership has since stated the vehicle is operating normally; I disagree, as I believe the root cause has not been resolved. Issues began at ~3,000 miles, with major failure at ~22,000 miles. I have contacted kia and requested a buyback due to repeated failures and safety concerns. This request was denied twice; a goodwill credit was offered but not accepted. This complaint is submitted to report ongoing safety defects involving stalling, braking, electrical failure, and a potential fire risk.
This is the 4th time car is unable to start after being parked for one day and it had to be jump starting. At first I thought it was some accessory, specifically a dashcam and aftermarket ambient lights, so I disconnected both and I even turned off the wireless charging pad and disable the function to turn the lights on when doors open and it didn't help, dead car again after 1 day parked. Car was purchased new in August of 2025 and this issue started this past January coincidentally after an ota update in December. Today, I got the 12v battery tested at my local advance auto parts and battery health came out good, battery level was low (as supposed after a jump start) and it only recommended a recharge. So the issue lies inside the electrical system of the car and to my surprise this parasitic draw is not new, in online forums a lot of owners talk and complaint about this specific issue, even here I found a similar complaint and I wonder why there's not at least a technical bulletin from kia addressing this issue. Finding out the cause of the battery draining fast is imperative because if overlook this can evolve into something more serious because we don't know what it is that is "always on" drawing big amounts of power and can clearly be classified as a fire hazard. I remember having the same issue with my old car, a 2019 kia Sorento ex, and it was solved with a simple computer update (not the map or infotainment update), it was a firmware only available at the dealership. I just hope this could be the case this time and kia can respond in a timely manner to solve this issue.
Vehicle only has 5839 miles and this is the 2nd time the battery has been dead. First time was Dec 18th 2025. Vehicle purchased 7/5/25. 2nd time 2/5/26. First time the outside lights flickered for a long time before finally going off. 2nd time the outside lights didnt flicker and key fob wont even lock the car. We took the vehicle in for service after 1st dead battery instance and they told us we must've not closed a door or left a light on which drained the battery. Will be scheduling another service so they can fix the issue. There were no messages or symptoms of the problem prior to the failures. I am requesting that NHTSA document this as a potential electrical system safety defect.
Was driving home from work, and suddenly all the indicator lights came on on the dash, (check engine, warring lights, indicator that the battery was critically low, etc etc. ) the car notified me to safely pull off the road. I pulled off the road in limp mode, the engine would not engage when pedal was pressed, and then lost power. I was stuck in the middle of the lane on a side road in park. I turned the car off, then turned it back on and let it idle for a bit thinking it may be the battery (which is new). After several minutes drove it home and have not had any other issues. I researched this issue on the internet and there were reported similar problems exactly like this. Note. I put it on a reader at home and it did not show any codes.
The kia connect fuse was confirmed by gerald kia of naperville to cause a parasitic draw that cannot be fixed. The dealership had to remove the fuse after stating that no software update is yet available, and that numerous owners have had the issue. My car has died 7x with less than 7k miles on it and less than a year old. Bought new. They still have not put the fuse back in and kia has refused to issue a recall.
Road debris under normal driving conditions caused a puncture of the inverter radiator resulting in a total loss of coolant in the inverter and battery system. Inspection of the system at a kia dealer confirmed the problem. The first sign of concern was an error displayed on the driver screen stating, "check drive motor cooling system". There is no mention of this error in the owner's manual for the vehicle, though I did find several online discussions surrounding similar issues and warnings. I was driving on the highway at the time, and outside temperature was just under 40 degrees f. The car continued to drive normally for roughly 15 miles while utilizing the gas engine on the highway but eventually began struggling to accelerate or brake when switching to the electrical system after moving to residential streets. There is not a means of turning off the hybrid system. I received further warnings for several various driver assist functions becoming unavailable and the car became difficult to steer. I parked in a parking lot until the car could be towed for evaluation.
Vehicle: 2025 kia Sorento (leased) VIN: [xxx] mileage at failure: 11,345 incident dates: March 23, April 27, November 28–December 1 type: loss of power / electrical failure / safety hazard complaint description: I am reporting repeated electrical failures and complete loss of power in my 2025 kia Sorento that created unsafe situations for myself and my children. The first failure occurred on March 23, approximately 2½ weeks after leasing the vehicle. The vehicle died without warning and had to be jumped. I brought it to the kia dealership, but service would not perform a diagnostic without an appointment and sent me home with no repair. The second failure occurred on April 27. This time the vehicle was completely dead again. Kia’s service manager retrieved the vehicle from my home, diagnosed a failed battery cell, and replaced the battery. The third failure occurred between November 28 and December 1. The vehicle was again completely inoperable. I attempted to jump the vehicle on multiple days, but it would not hold a charge. I was stranded without transportation. The interior doors and trunk would not unlock because the power locks failed, and my belongings and large business related were inaccessible. Headlights flickered like a strobe light before the vehicle lost power entirely. Kia towed the vehicle from my home on December 1. These repeated electrical failures have resulted in multiple incidents of being stranded, including with my children, and have caused loss of use of the vehicle for several days. The defect is unpredictable and creates a serious safety concern, especially because the vehicle can lose power without warning and I am unable to unlock the doors. This raises a serious safety concern when transporting children. I am requesting that NHTSA document this as a potential electrical system safety defect. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
Beginning at approximately 750 miles on a brand-new 2025 kia Sorento hybrid ex, the vehicle experienced a flashing check engine light accompanied by severe shaking while driving, rough idling, loss of power, and loud engine/exhaust noise. The vehicle became difficult and unsafe to operate due to the vibration and reduced drivability. These symptoms appeared suddenly on November 22, less than three weeks after purchase. The vehicle was taken to the dealership on November 24. Their technician retrieved diagnostic codes p0300 (random misfire) and p0304 (cylinder #4 misfire) and identified a failed ignition coil on cylinder #4. The coil was replaced, and the dealership reported the issue resolved. However, less than 24 hours later, with the vehicle still under 800 miles, the exact same symptoms reoccurred: heavy shaking while driving, vibration while idling, loss of power, and unstable engine operation. This indicates the underlying issue may be more serious than a single coil failure. The problem has been reproduced and confirmed by the dealership, and the vehicle is currently back in their possession for further inspection. A loaner vehicle was issued because the vehicle was not safe to drive. The sudden shaking, engine misfire, and loss of power created a significant safety risk, especially if this failure were to occur at highway speeds or while turning across traffic. Given the extremely low mileage and recurrence immediately after repair, this may indicate a broader defect affecting engine performance or ignition components in this model. The vehicle remains available for inspection by NHTSA, the manufacturer, or investigators.
Fourth time we've had the car go into limp mode. Now at the dealer for third time. Driver was driving and the car went into limp mode after activating the cruise control follow function. Husband was behind in our Toyota tacoma truck and was able to pick her up with California highway patrol to get off the highway into a parking lot to tow her. No warnings, no messages on the dash. She was unable to accelerate to highway speeds and was capped, and felt that there was very little to no predictable responsiveness in the car's acceleration. Car now at dealership.
Safety concern – 2025 kia Sorento prestige hybrid (VIN [xxx] ) around October 13, 2025, my leased 2025 kia Sorento prestige hybrid experienced a sudden and severe loss of power while I was driving on the highway. The vehicle was towed to the dealership, where the high power control unit (hpcu), part number 36601-3dpg3, was replaced. No clear explanation of the root cause was provided. Less than a month later, on November 6, the same failure occurred again—this time in heavy highway traffic—creating a serious safety risk and increasing the chance of a collision. The vehicle is primarily driven by my wife, who regularly uses highways to transport our son. The recurring and unpredictable nature of this issue has made us feel unsafe and anxious. We are deeply concerned that another failure could lead to a serious accident or fatality. We respectfully request that the national highway traffic safety administration (NHTSA) investigate this matter as a potential safety defect. Without a clear understanding of the cause, we are documenting these incidents to encourage action. It is critical that kia resolves this issue to protect families and maintain trust in its brand. Thank you information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
On 10/3 driving at roughly 60mph on the freeway, when going to accelerate, the vehicle would not accelerate with no power going to the engine. The gas motor was not engaging, and the car rapidly decelerated to around 20mph in an incredibly unsafe situation. Coasting it off the freeway, it was towed to the local kia dealership. No warning lights or any indicators went off during that event. 10/9/2025, I picked up the vehicle after they replaced the high-pressure fuel pump and high-pressure fuel line, I noticed the battery was very low and thought it would charge while driving. As I left the dealership, the vehicle did not engage the gas engine and quickly avoided acceleration - no power was going to the engine. The battery reached a catastrophic low, and the engine failed in a busy intersection - creating another extremely unsafe situation - as I was turning around to return to the dealership. This time the hybrid system warning system went off and the battery and oil lights went on. While waiting for the tow truck, the vehicle would not turn off. It is currently with the dealership, 41k miles on vehicle, 1 year old.
The driver’s door windows/lock button cluster on my 2025 kia sorrento lx will randomly not work. None of the buttons will work so I am unable to roll any of the windows down or lock or unlock the doors. The only way to fix this is to turn off the car and restart it.
There is an electronic glitch with the gear shifting system where it will randomly / sporadically not allow shifting from reverse to drive and provides the error message "gear already selected. " this has happened numerous times and resolves itself after 1-2 minutes. However, the vehicle remains in the wrong gear (reverse) while waiting, creating a significant safety issue. I purchased this vehicle brand new from kia coughlin in dublin, OH. After two service visits where they were unable to recreate the problem (it happens randomly / sporatically), they have not provided resolution or a way ahead. I have multiple videos of this issue taken while it was happening.
August 18, 2025 at 3pm pt; my 2025 kia Sorento x-line was parked in my driveway facing the street. I had the engine on, and in park mode, ac on, back hatch door open. No one was in the vehicle. I was standing behind the vehicle when it then started to go in reverse, then stopped for 2 seconds. It then proceeded to go into reverse again. The garage door was open. The vehicle pushed me into the blades of our lawn mower (it is stored in the garage on its end, so the blades face the garage door), and continued to push me and the lawn mower into our gardening tool supply rack. I did all I could to stop the vehicle with my body and yell for help. I was trapped. The vehicle eventually stopped because the back hatch door was open and caught on the upper part of the garage frame. I got myself unstuck and got out to the right, and went straight to the passenger front door to check out the gear shift. It was still in park mode. All was captured on our ring camera. I called kia corporate customer service and received a case number (25476533) and was told I would hear back in 10 business days. This was after calling the dealership twice directly (elk grove kia) leaving a detailed message with no response.
Was turning right onto the road when the steering locked up and every safety warning light came on. My car literally stopped moving in the middle of the road. I wasn't literally right down the road from my house so thankfully I was able to get the car back to my house. The steering felt worse than not having power steering. I called and the dealership matt blac kia of toms river, and they had my car towed to the dealership around 10 am on April 4th. Around 4pm I was told they still had no idea what was wrong with my car, and to come pick up a loaner car. On April 5th at 4:42 pm I received a text stating the wiring harness wasn't secured properly and rubbed the steering shaft, and they had to contact kia to see how to proceed. April 11th was told the part arrived and hopefully sometime next week I would get my vehicle. As of right now I still don't have my vehicle and have no idea of when I will get it back. My main concern is that this was a serious oversight on the assembly of this car, and could have had very different results if I was not in my neighborhood and was on a busier road.
The contact owns a 2025 kia Sorento. The contact stated that upon purchasing the vehicle brand new from the dealer and driving the vehicle to the residence, the contact became aware that the VIN was included in NHTSA campaign number: 25v006000 (electrical system, exterior lighting) after conducting a VIN search the same day. The dealer and the manufacturer were not contacted. The mileage on the vehicle was 10. The actual mileage was 530.
While driving this warning alert will show up on the screen of my vehicle. It is important to note that this happens while driving and when no one is using their phone or using the touchscreen of the car. No one is ever searching something on their phone or on the car’s touchscreen system.
The front and rear passenger side windows of my 2025 kia Sorento intermittently fail to operate. When attempting to roll them down, all that can be heard is a clicking sound, and the windows do not move. This issue occurs randomly and without warning. The malfunction poses a safety concern, as functioning windows are necessary for proper ventilation, emergency egress, and communication with others outside the vehicle, including law enforcement or toll booth operators. The issue was first reported to kia of bowie on December 9, 2024. However, the dealership stated they could not recreate the problem and, therefore, could not make repairs, citing that kia would not reimburse them unless they could verify the defect. I was advised to record a video of the issue should it occur again. The problem has persisted multiple times, but due to being the driver, capturing a video was difficult. I was recently able to record the malfunction, showing both windows failing to operate with only the clicking sound audible. On February 17, 2025, I returned to the dealership with a scheduled appointment to address this issue. After waiting 2. 5 hours, I was informed that they again could not recreate the issue and that my video evidence was not considered sufficient for a repair. Despite following the dealership's instructions, no resolution has been provided. Additionally, my kia connect system is not functioning properly, and the radio sound intermittently cuts in and out. These electrical issues raise concerns about potential broader system malfunctions that could compromise vehicle safety. No warning lights or error messages have appeared related to these issues. The vehicle remains available for inspection upon request.