Table 1 shows one common steering related problems of the 2023 Mazda CX9.
| Problem Category | Number of Problems |
|---|---|
| Steering problems |
Starting [xxx], through [xxx], we began receiving multiple "critical vehicle malfunction" alerts (46 alert messages)via the Mazda app, including "parking brake malfunction" and "electric parking brake malfunction. " during this time, the vehicle experienced delayed starts and eventually required a jump-start. We brought it to the dealership multiple times to show the messages, before our 3-year/36,000-mile b2b warranty expired, but the issues were dismissed until the battery was finally replaced. At just over 36,000 miles (currently 39,646), a new issue emerged a “thud” sound from the steering wheel. The dealer diagnosed it as a failed u-joint shaft, which was deemed non-serviceable and not covered under warranty. I inquired about potential causes or prevention—no clear answer was known. I found relevant NHTSA tsbs (06-001/20 & 06-001/24) related to steering issues and escalated to Mazda USA. Mazda agreed to cover 50% as a goodwill gesture, leaving me to pay about $500. Two weeks later, the part arrived and was installed—but it did not fix the issue. The dealership now says it’s a failed bearing within the electric power steering (eps) unit, which requires complete replacement at a cost of over $2,000. Only one part is available in the u. S. , with another two-week wait. The original (misdiagnosed) part was already sent back to Mazda. My out-of-pocket cost is now $1,151 and rising. Given the early warning alerts, misdiagnoses, and the fact that eps controls several safety-critical functions (steering, cruise, lane assist, etc. ), I believe this is a fundamental system failure that should be fully covered under warranty or as a safety-related goodwill repair. I respectfully request that Mazda assume full financial responsibility for the replacement and any related work. Thank you for your consideration. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
The contact owns a 2023 Mazda motor corp. The contact stated while driving at 30 mph, the power steering seized and the brake pedal locked was inoperable. The contact stated as a result of the failure, the vehicle crashed into a ditch and crashed into a tree. The contact stated that the air bags did not deploy. The contact stated that his wife was a passenger in the vehicle and was seated on the front passenger seat. There were no injuries sustained. The front driver side of the vehicle was damaged during the crash. No police or fire report was filed. The vehicle was towed to the contacts vacation home in wisconsin. The contact stated that the vehicle had been previously been serviced by the dealer on four occasions due to failed software update. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 12,100.