Other Fuel System Fuel Gauge Problems of Mercedes Benz ML320

When filling the vehicle with fuel, the fuel gauge does not give a proper reading. Manufacturer serviced the vehicle 6-7 times, but couldn't find the cause of the problem.

See all problems of the 2003 Mercedes Benz ML320 🔎.

Fuel gauge does not read correctly/run out of fuel/engine quits loss of control, power brakes and steering may lead to crash/defect.

See all problems of the 1999 Mercedes Benz ML320 🔎.

The defect stated in recall 03 v 121 000 for the power steering hose clamp happened while the consumer was waiting to be notified. The consumer experienced the following: the entire instrument cluster lit up and flashed and beeped, lost the speedometer, tachometer, gas/gas temperature gauge, and the vehicle had gone into second gear and did come out for some time(discovered it was in limp-home mode). The service dealer advised the consumer that the problem was the gear selector. The instrument cluster lights had gone off, except for the bas/brake assist system light, the gauges, speedometer, and tachometer had resumed. There was an incident where half of instrument cluster display on the left lit up, although the vehicle continued to run. The service dealer thought the problem may have been the battery. During a rainstorm, the entire instrument panel lit up, the tachometer, speedometer, and the gas gauge stopped and the instrument panel kept beeping intermittently but did not go into limp mode. There was a crack in one of the d-pillars, and the rear hatch lock did not work. The ignition lock seemed loose since the gear shift assembly had been replaced, the windshield washer reservoir leaked. The bas/esp control module had been changed, but the problem persisted. The consumer was told the vehicle needed a new battery. The brake pad wear light displayed, the power steering had failed again. The consumer was advised the vehicle needed front and rear brakes then was told that it was a clamp problem. Also the driver's window switch hesitated. The safety recall notice that related to the failure of the hose clamp for the power steering fluid which apparently caused the complete loss of power steering in the vehicle as well as damage to the hydraulic fluid pump which resulted in repairs performed on the vehicle. The consumer requested full reimbursement for the charges related to the repairs. Recall# 03v121000.

See all problems of the 2001 Mercedes Benz ML320 🔎.

Fuel tank sender to fuel guage failed. Yh.

See all problems of the 1998 Mercedes Benz ML320 🔎.

Fuel gauge sending unit failed. Yh.

Fuel gauge failed. Yh.

Vehicle was always being serviced and the air bags failed to deploy in a severe accident. The consumer was struck by another driver and caused damage on both sides of the vehicle. Both sides of the doors were smashed and there was extensive damage in the passenger's cabin. Other problems are as followed: the engine light was on, engine low level oil light had come on, when the right front and left rear windows were erratic when going down, the cigarette lighter was inoperative, the rear cargo accessory plug was inoperative, the trim on the left side of the left front seat cracked, there was a buldge on the right rear tire, lug bolts were missing on the right rear wheel and the rear pads needed to be replaced, there was a noise heard in the rear when going over bumps, the power supply plug in the rear cargo area was inoperative, the light behind the climate control panel was inoperative, the left front window was intermittent, the left front park light was inoperative, the left front door was not closing due to the latching, the rear electrical plug in the rear cargo area was inoperative, the material on the center console wrinkled, the sunroof would bind when opened, the rear tire had a knot on the sidewall, when the vehicle was filled with fuel the fuel gauge would go down, there was a noise in he right front wheel when driven at low speeds, there was a whining noise when turning the steering wheel and the steering was stiff.

See all problems of the 2000 Mercedes Benz ML320 🔎.

Wires on the fuel sending units corrode in gasoline and send false electrical signals to the fuel gauge.