Two problems related to body have been reported for the 2008 Mini Cooper. The most recently reported issues are listed below.
8;30 am three car intersection accident. Traffic light controlled 4 way intersection, auto traveling south bound ran red light and collided with two cars traveling east bound through intersection at approx 35 mph. . 1st car impacted Toyota Mini van drivers side. Force of accident so severe that it forced Mini van into my auto. The Mini van impacted my Mini primarily into my drivers side door. All three vehicles had to be towed from scene of accident. My Mini Coopers drivers side door demolished. Force of impact so great the it bent the frame underneath the drivers door 3-4 inches according to the repair facility it was towed to. Vip auto body. The window that was approx 1/3 open shattered the window. I sustained injuries to neck, back,shoulder and right side of head which hit the door panel upon impact. I have done extensive research since this accident and there are several air bags and side door impact bag curtains in the Mini Cooper and none of them deployed. There is an actual sensor in the middle of each door to activate the air bags, obviously the one in the drivers side door was not working. This car supposedly has a 5 star crash rating according to Mini USA and my original window sticker. I contacted Mini USA the day after the accident, and they instructed me not to have any repairs done until one of there tech's came out to inspect the Mini and do a diagnostic check of the air bag system. I did so. The tech came out 5 days later, and a week after that the results came in and Mini USA said everything was working properly as far as the air bags. Liars. Anyone with any common sense can see that the air bags should have deployed with the force of this impact. They just don't want to take any responsibility for this accident. My Mini Cooper was deemed a total loss. Any investigation into this accident would be very appreciated maybe even saving a life in the future . . . . Updated 04/23/15.
My wife and I live in munich, germany, where she works for the us government. Last Wednesday, while on the autobahn our car began to make sounds as if it was driving through a puddle or that there was some sort of fluid being splashed on the undercarriage of the car. Because it was a sunny day, I knew something was wrong and I was preparing to pull the car over to investigate the cause of the sound. Before I could do so however, I heard a popping sound and suddenly the car became flooded with a thick white/gray smoke from the vents and dash. I pulled over as quickly as I could and by the time I got out of the car, the entire hood and inside cabin was engulfed in smoke. Rather than pop the hood, I first ran to the trunk and grabbed a reflector (which is required by law here) and ran 20-25 feet behind the car to place it on the ground, to warn oncoming traffic. No sooner had I done this, when I head an explosion, quickly turned around and saw that the entire front half of the Mini was now engulfed in flames. I could do nothing but sit and watch, as within moments the fire had spread throughout the rest of the car and soon became an complete fireball. German police and fire officials showed up 15-20 minutes later and by the time the fire was extinguished, all that was left was a charred frame of metal. Fortunately I was not physically hurt by the explosion or the fire. However, mentally I have replayed the experience a hundred times and each time I ask myself, what if I had popped the hood first, or what if I had taken even an extra 30 seconds in pulling the car over? thinking about it just makes my blood run cold and feels me with dread. We purchased the car in '08 in virginia and never had any issues with it and it was even in the shop earlier this year, where the fluids were all topped off and everything was told to be in excellent running condition.