Body problems of the 2004 Nissan Quest

We recently had to change the alternator and noticed on the passenger side front the subframe has a large hole in it and is completely not safe to drive and nothing has been hit there and it has not been in an accident related to that area at all, vehicle was parked at my home when this was found and still is I did not take any pictures at that time of the rotting hole in the subframe I can get pictures but we will have to remove right side front tire so please let me know if this has to be done.

I took the vehicle in for some maintenance/repair to the front axle on 1/16/2020 and the mechanic found that the subframe on the passenger side of the vehicle by the front tire was severely rusted to the point where he can push his finger through the side of the frame. He told me he could not believe I had not had an accident because in his opinion hitting a medium size chuckhole in the roadway could cause the right front of the vehicle to completely collapse. The mechanic indicated this did not happen overnight and has been ongoing. The vehicle has been parked in a garage at my home during its use since it was purchased new by me and not routinely left parked on the street. The mechanic advised me that in his opinion it was not safe to drive the vehicle very far.

Subframe rotted.

I am writing due to the fact I took my 2004 Nissan Quest into the shop today because of a loose steering wheel and a horrible clunking noise coming from the front right side. My van only has 97,000 miles on it and has been taken care of very well. The mechanic told me the the subframe is basically rotting away and is the worst he has seen in 50 years of work. I've read numerous accounts online of other who have had this same issue. I feel like Nissan should help cover the cost of my repairs due to poor manufacturing and poor quality of parts. I am very unhappy and will be sharing my story with whoever I can share it with. I will include a link with a site with many complaints from other owners of this same vehicle. Please help me out. This is a big issue because my wife and three children ride in this vehicle daily. . Read more...

Tamara inflators, sent my van to my local Nissan dealer for brake repairmen. I was told since the front subframe at passenger side had severe rust area, my van is not safe to drive. It will cost me more than $4,000 to replace. I checked internet. There are many same problems occurred on 2004 Quest. It looks like the defect of materials to me.

The contact owns a 2004 Nissan Quest. The contact stated the sliding door latches failed to function properly for the rear doors on both sides. The contact had to check the doors to ensure that they were secured and when the failure happened, the contact had to manually close the two electric doors with force. The vehicle was excluded from NHTSA campaign number: 04v186000 (latches/locks/linkages) and NHTSA action number: pe04027 (structure, latches/locks/linkages) but the contact had experienced the failure concerning the recalls. Two dealers had been notified (busam Nissan,1501 e kemper rd, cincinnati, OH 45246,(513) 771-8100 and jeff wyler Nissan of cincinnati, 8680 colerain Ave, cincinnati, OH 45251, (513) 385-1400). The contact was to check with the manufacturer to determine a remedy to repair the vehicle. The contact was uncertain if the manufacturer may provide a solution being excluded from the recall. The failure mileage was not available.

I took my car to the mechanic for an alternator, my mechanic discovered that the front subframe of the vehicle was rusted almost through and deemed the car unsafe to drive. We located a used subframe with difficulty because many of them were like this. Seems to be a problem with the frame in this vehicle. If it had cracked there would have been an accident. Nissan north America is uninterested because I did not go to the dealer. I have the rusted part.

I got out of the car, turned it off and went on the house minutes later the car was on fire. The flames were big and they were in the front passenger side of the engine. I had just drove the car about an hour, there was no smell no sound no indicator lights nothing. The flames were big and car went up fast.

The contact owns a 2004 Nissan Quest. The contact stated that the automatic sliding door became partially jammed. The contact attempted to close the door manually and noticed that the door was not on track. The vehicle was not taken to the dealer for inspection. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 120,000. The VIN was unavailable.

Driving my 2004 Nissan Quest with approx 61000 miles at 55 mph on local highway when it sounded like the side of car was hit. I pulled over and found my passenger power sliding door rail cover, a piece (~4ft by 5 to 8 inches) had nearly completely detached from the car except for bent back bracket. I could not remove (piece wedge into tail light) so I pushed it in as best as possible and drove home. Very fortunate the piece did not detach completely and hit the vehicle behind. This could have caused some serious damage, maybe even hurt someone. I found other reports of this safety/design problem occurring with 2004 Quest. The metal cover was bent, the taillight assembly cracked around the edge and some nasty scratches in the paint. This piece is attached by small plastic grommet clips that seem brittle. Poorly designed since the rear is attached under the taillight and the front with plastic clips. If they would have put the metal tab in the front also this would have never happened. Took it to the dealer in kennesaw,GA and they said it would be $700 to fix and it would not be covered as a manufactures defect. Called Nissan corporate and they dragged their feet for a few days and called me back and said they would assist in any way due to being out of warranty. It is a real shame because I have had 2 Nissans previously (trucks) and I will probably never buy another Nissan. Corporate was very cold and short, zero customer service in mind.

My Nissan Quest 2004 has problems with the sliding door- it opens but closes immediately - almost trapping my 4 year once. Also, it does not lock fully and so there is a beeping sounds when the van is started and driven for a while, when closing the door from the button inside, there was a noise and beep and it would not close at times until 3 or 4 trials.

Children was entering vehicle and door spontaneously closed on hand. This has happened periodically since, but never with the exact same circumstances. Ie opened door to load packages, turned back around and door started closing.

I bought a Nissan Quest 2004 van from broad street Honda dealer at richmond it has serious door problem which was not locking completely and it is obviously not save for my three children. I took the van to them and the don't want to fix the problem even it is under their warranty for 3000 mile or three months even I also bought from them an extended warranty but it is useless they said even I paid 14000 dollars of it. They simply want me to give the car to them bellow the price I bought from them. I believe it is fraud a clear fraud. Please help me.

I was driving my 2004 Nissan Quest (with approx 60500 miles) at 55 mph on local highway when it sounded like the side of car was hit. I pulled into the nearest gas station and found that my passenger power sliding door rail cover siding piece (~4ft by 8 inches) had nearly completely detached from the car except for bent back bracket. I could not remove (piece wedge into tail light) so I pushed it in as best as possible and drove 20 miles home. The piece fell off completely in driveway when I opened passenger door. I am very fortunate the piece did not detach completely and hit the car behind me when I was traveling 55 mph. I googled and found 2 other reports of this safety/design problem occurring with 2004 Quest. Other than the single bent bracket and a bit of chipped paint on the edge that has wedged under the tail light--this piece and my car show no other signs of damage. I was not hit by anything--so either this piece was not properly attached or the attachment is not properly designed.

Our 2004 Nissan Quest which we purchased new is rusting around the sun roof. We have had numerous problems with the van. For a vehicle less than 5 years old, and has been garage kept, I believe rust in this location is a defect in the vehicle. When my dealer said he would not cover fixing the rust, I took the van to a body shop, and the owner was so appalled by the rust, that he called a different Nissan dealer, who agreed and recommended we file a claim to Nissan's claim office. After several weeks, and having to take the van back to the dealer 4 times, the claims office stated that since the van is out of warranty, it is not covered. My claim number with Nissan is 6336483.