Two problems related to front suspension wheel bearing have been reported for the 2009 Toyota Tacoma. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2009 Toyota Tacoma based on all problems reported for the 2009 Tacoma.
My 09 Tacoma vibrated at certain speeds and slightly swerved going down the highway causing instability and lack of control. Also heard some clanking in the rear end. Upon examination the rear leaf springs in both sides were broken. According to the mechanic one spring was actually rubbing the tire . Toyota had numerous recalls for Tacoma rear leaf springs because they were breaking. However, when I called Toyota they told me my vehicle came from a different plant and did not qualify. I never abused this vehicle no reason for this issue they should add this plant to the recall list to avoid accident and injury. I should disclose that I had two bad wheel bearings as well which may have resulted from the stress caused by the leaf springs. Just dont know. However, not just a coincidence that both springs broke on a Tacoma that is well known for this problem. Thank you.
At 59,500 miles the left front wheel bearing started making a lot of noise and vibration and noticeably altered the steering. The wheel bearing was replaced under warranty. Now at 90,000 miles the bearing is faulty again and Toyota refuses to fix it again. I took it to my mechanic who told me that he sees a lot of failed wheel bearings on the Tacomas. A failed bearing can result in the wheel locking up or falling off at highway speeds.