22 problems related to front suspension lower ball joint have been reported for the 2005 Toyota Tundra. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Toyota Tundra based on all problems reported for the 2005 Tundra.
Tl the contact owns a 2005 Toyota Tundra. While driving 5 mph, the front driver's side wheel fractured and the lower ball joint fractured. The vehicle was towed to an independent mechanic to be repaired. The contact stated that the vehicle was repaired per NHTSA campaign number: 07v013000 (suspension). The manufacturer was contacted and confirmed that the vehicle was repaired per NHTSA campaign number: 07v013000 (suspension). The dealer was not contacted. The approximate failure mileage was 216,000.
The contact owns a 2005 Toyota Tundra. While driving 10 mph, the lower ball joint separated without warning. The contact pulled the vehicle over to the side of the road. The vehicle was towed to the contact's residence. The contact replaced the lower ball joint. The vehicle was then taken to the dealer (american tire & wheel inc, 115 mall st, hot springs, ar 71913) and they checked and replaced all the parts at the front end of the vehicle. The vehicle was repaired. The manufacturer was contacted at 800-331-4331 and stated that the recall had already been repaired. Case number: 1709200139 was provided. The approximate failure mileage was 175,000.
The contact owns a 2005 Toyota Tundra. While driving approximately 35 mph, the contact heard an abnormal noise coming from the front driver's side tire. The vehicle became inoperable as the front driver's side wheel detached from the vehicle. As a result, the front of the vehicle hit the ground. The contact was able to pull the vehicle towards the right side shoulder of the beltway. There were no warning indicators illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the upper and lower ball joints fractured, damaged the abs sensor, and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 128,000.
The contact owns a 2005 Toyota Tundra. The contact stated that while driving 45 mph over a bridge, there was a loud noise and the vehicle immediately lowered. The contact stated that the rear driver's side tire exploded. The vehicle was towed to a dealer where it was diagnosed that both the lower and upper ball joints snapped and caused the rear driver side tire to explode from the force of the impact. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 158,000.
Received recall ssc 70b-front suspension lower ball joint safety recall noticere on or around 6/07/07. Called dealership for appointment to replace, heather in service said they would have to order the part and it would take 3 to 6 weeks for them to receive, at that time they would call me for an appointment. I said that was a long time to wait and she said they only get 5 at a time once a week or every other week, that it was a national recall. My point was then shouldn't there be more of these parts available with a shorter wait time. Very upsetting about the delay in getting the part replaced, as it seems according to the recall notice a possiblity of a crash may occur do to the defective part.
I have a safety recall on the 2005 Toyota Tundra for the lower ball joints. I took it to the dealer were I purchased the truck and they told me 6 to 8 weeks for just the parts to come in. I drive on the interstate a lot, and there was shimmying in the front end. I told the dealer that, and the service technician told me if they break they will put me in a rental. What if they break and I am killed or somebody else dies. I think this is a big problem.
The contact owns a 2005 Toyota Tundra. On may 14, 2007, the contact received safety recall notice # 07v013000 (suspension:front:control arm:lower ball joint) and has been unable to schedule an appointment ever since. No failures have occurred, but she is fearful of driving. The engine size was unknown. The current and failure mileages were 20,000.
The contact owns a 2005 Toyota Tundra. The vehicle was taken to the dealer on April 2, 2007 due to a noise coming from the front end. The dealer test drove the vehicle and stated that everything was normal. On may 13, 2007, the contact heard a loud noise while accelerating from a stop at 2 mph. The left front tire detached and the ball joint split in half. The vehicle has since been repaired. The engine size, # of cylinders, and current and failure mileages were unknown. The consumer stated the dealership is at fault. The consumer provided a repair invoice for vehicle. Updated 08/07/07.
Tl- the owns a 2005 Toyota Tundra. He states that he received a recall notice a few weeks ago and he has called various Toyota dealers in the area to have his recall serviced for the lower ball joints. He states that all of the dealers have told him that the parts are not available. They told him to keep checking back once a week because they have not been available for two months. Recall number:07v013000:suspension: lower ball joints. Failure mileage: 70k. --ds.
The contact owns a 2005 Toyota Tundra. The contact received recall notice # 07v013000 concerning suspension:front:control arm:lower ball joint. The contact called three different dealers, and was informed that none of the dealers in puerto rico have the part to fix the recall. The dealers were unable to determine when the part would arrive. The contact was currently on the waiting list for two dealers. When depressing the brake pedal the contact heard a noise coming from underneath the front of the vehicle. The noise magnified when traveling below 45 mph under any driving conditions. The current mileage is 27,000, and failure mileage was unknown.
Recall on Toyota Tundra in 2007. The ball joints were found to be defective because of a hardness issue on the surface treatment of the ball. The failure would be a premature wearing or failure of the joint. Toyota did issue a recall and repairs made to the vehicle. After the repair the vehicle had a hard pull to the right and vibration that did not exist prior to the repair. After taking it back to the dealer, they found the steering wheel and front end out of alignment. The dealer repaired these but did not fix the problem. After a total of 4 visits over a 6 month period the vehicle still has a dangerous pull vibration. The dealer cannot repair the problem.
The contact owns a 2005 Toyota Tundra. In April of 2007, the contact received recall notice # 07v013000 (suspension:front:control arm:lower ball joint). The dealer stated that they do not have the parts available to repair the recall. He would have to remain on the waiting list. The contact has notified other dealers in the area and surrounding states and they have given the same response. The current and failure mileages were 27,000.
The contact owns 2005 Toyota Tundra. A month ago she received a notice to have the front: suspension: lower ball joints replaced per recall number 07v013000. On numerous occasions the Toyota dealer and manufacturer stated that the parts were on back order, there were 45 owners ahead of her, and they may be able to service her in two to three months. She contacted every Toyota dealer in her area, and they were also unable to assist her. A local Toyota dealer also advised her that parts where not ordered under her name which was causing the delay. She filed a complaint with Toyota. The current and failure mileage were 17,600.
The contact owns a 2005 Toyota Tundra. On April 1, 2007, the contact received recall notice # 07v013000 (suspension:front:control arm:lower ball joint). The dealer stated that his name would be placed on a waiting list because they were only receiving approximately two or three parts per week. As of July 18, 2007, the vehicle has not been repaired. No failures have occurred at this time. The current mileage is 75,000 and the failure mileage was inapplicable. Updated 02-01-08 the consumer stated the ball joints were replaced. Updated.
The contact owns a 2005 Toyota Tundra. In March of 2007, the contact received recall notice number ssc70b (suspension: front: control arm: lower ball joints). An appointment was scheduled for July of 2007 since the parts were unavailable. The dealer has not notified him if the parts were available. Another Toyota dealer is 90 miles away. The contact is aware of the safety risk involved. There had been no failure to date. The current mileage was 18,463. Updated 01/11/08. Updated.
My 2005 Toyota Tundra was in for service the mechanic said there was a recall on this truck so I agreed to let Toyota replace my ball joints (recall 70b) after the replacement was done the vehicle steering began to fade to the left and then to the right I returned to the dealer and he said that it needed a few adjustments after driving it again the problem still existed after driving the truck for a few months I found that my tires were wearing due to feathering to the right and left also the vehicle became hard to hold straight in line while driving when I would run over a small depression in the road the steering would pull me in to oncoming traffic. I drove the truck back to the dealer 08/06/2007 they did a series of test but nothing worked. Final words you just have to live with it. I contacted Toyota consumer complaint line and low and behold a recording came on addressing symptoms with the Tundra the deal is I did not have this problem as they described it on the recording until after they replaced the ball joints.
I have a 2005 Toyota Tundra with 24,000 miles and have experienced 3 issues. 1 brake failure on off ramp. 1/2/07 lower ball joint replacement- recall by Toyota. 7/9/07 left rear wheel bearing replaced 8 /14/ 07 all of these problems were addressed by Toyota of temecula. Toyota has increased the brake size on new Tundra trucks. Why? these are quality and safety issues and I am wondering when the next problem will happen. Updated 09/26/07.
: the contact stated while pulling out of the driveway at 2 mph, the front left side of the vehicle dropped down to the ground without warning. The vehicle was towed to and authorized repair facility, who determined that the left front lower ball joint fractured and needed to be replaced. The manufacturer was alerted. Updated 1/19/2007 -.
Driving wb on hwy 4 near douglas flat, CA approx 55 mph on two lane highway. The 2005 Toyota Tundra 4wd driver side front wheel detached, folding under front left side frame behind wheel well with the truck landing on the flat side of the wheel. I was then in a controlled skid on a straight part of the highway and held the steering wheel in that position. I did not apply the brakes as I did not want to alter the direction of the skid. The vehicle drifted slightly to the right after about a 150 foot skid. The wheel hub had separated from the upper and lower control arm, the ball joint had detached from the a-frame, and the wheel and tire (replaced two weeks prior) were damaged. The only thing apparently holding the wheel to the frame was the steering rod. Not being a mechanic or had the vehicle looked at by a mechanic as yet I am not sure of all damage sustained. Pictures of the scene show a single skid mark on the drivers side. I contacted my Toyota dealer who didn't seem to interested since there were no injuries. This incident occurred with 72,000 miles on the truck meaning that the 36 month, 36,000 mile warranty would not cover the damage. In researching the ball joint complaint I found that there was a recall on the 2004 Tundra. It was lucky that I wasn't injured since the previous day I had been returning from a job site via nb parrotts ferry road which is about a 1000 ft descent on a curving road which in several places drops off into the canyon and reservoir below.
The contact owns a 2005 Toyota Tundra. While driving 65 mph, the vehicle shakes and pulls to the right side. The contact has taken the vehicle to the dealer three times for an alignment. The failure persists and the dealer was unable to determine the cause. The lower ball joint was also replaced. The powertrain and mileage information were unknown. The consumer stated the truck is not running right, he further stated took to the dealer and they check the tire pressure and do an alignment but it does not remedy the problem. The consumer stated requesting dealer to find out what is wrong with the truck. Updated 08/01/07.
2005 Toyota Tundra recall on lower ball joints. Consumer would like information on making an appointment with the dealer.
Toyota Tundra with ball joint replacement. Consumer states they would not give him copies of the other invoices he signed. Consumer wants to know why they wouldn't give him copies. The consumer stated when he arrived home, he looked under the vehicle and it appeared that no work had been performed on the suspension.