Two problems related to other fuel system tank assembly have been reported for the 2009 Volkswagen Jetta. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2009 Volkswagen Jetta based on all problems reported for the 2009 Jetta.
Started the car and after about 5 minutes of driving, the engine shuts off but all electrical systems apear to be working. No trouble/ indicator lights come on. This has happened on the interstate traveling 70, on a side street traveling 35, and sitting iddle at a stop light. Every time, the car will run for between 5-7 minutes than not restart for 5-7 minutes. At attempts to restart inside that 5 minute window after the engine stalls, there is no turning over, no clicking or anything. There is no temp issues, or low fuel issues. This has happened on a full tank and a half tank also.
This car is a vw Jetta tdi (turbodiesel). Driving on I-96 between lansing and brighton the Jetta began to run roughly with a loss of power. The traffic was very slow due to a snowstorm, so I was able to continue driving. The car ran increasingly rough and eventually stopped. The car was towed to my local dealership, germain vw in ann arbor. The report was fuel system failure due to the hpfp breaking apart. The entire fuel system will need to be replaced and the fuel tank fully cleaned of metal fragments.