Other Fuel System Tank Assembly Problems of Volvo XC90

Engine stalled and shut down at highway speed of approximately 70 mph. Two consecutive tankfuls at about 1/4 tank or 135 miles to empty. Check engine light came on. Restarted engine and limped to nearest gas station. After fillup engine light cleared and it drove fine until down to approx a quarter tank again when it reoccurred.

See all problems of the 2010 Volvo XC90 🔎.

The vehicle gets a strong gas smell inside the driving area when gas tank filled. No fuel found to be leaking. Smell comes from under floor by backseats.

The contact owns a 2016 Volvo Xc90. Each time the contact attempted to fuel the vehicle, the fuel tank door did not open. The contact attempted to open the fuel tank door with the key fob and manually. The vehicle was not diagnosed or repaired. The dealer and manufacturer were not notified of the failure. The approximate failure mileage was 62,000.

See all problems of the 2016 Volvo XC90 🔎.

Bought the vehicle with 112,000 miles on it, it has a gas leak trickling down the side of the gas tank, probably a bad sending unit, fumes are bad some days but worse on warmer days. The transmission failed one day with no warning or light, it just lost momentum and failed to engage in drive. I think this is due to the poor engineering design Volvo used. This model is the t6 with the gm 4t65e transmission which is widely known to fail even at low miles. I think a full safety recall should e sanctioned for all model years with these horrible problems.

See all problems of the 2004 Volvo XC90 🔎.

When stationary the car will have a wet spot of fuel under the tank and when we come to a stop you can smell fuel. When I looked under the car you can see where the side of the fuel tank was wet or dripping fuel.

There is a recall dated March 2010 for 2003-2005 Xc90 for fuel system problems, I am having problems with my car having problems running. Engine analysis shows code po087and p0089, fuel pressure regulator. Car will not continue to run while driving with less than 3/4 full tank.

See all problems of the 2005 Volvo XC90 🔎.

The contact owns a 2004 Volvo Xc90. While the vehicle was parked, an extremely strong odor of fuel emitted near the fuel tank on the rear passenger side. The fuel tank exhibited fuel leakage, but there was no fuel visible on the ground. The contact experienced the same failure as mentioned in NHTSA campaign number: 09v483000 (fuel system, gasoline); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the issue. The approximate failure mileage was 215,000.

Tl-the contact owns a 2004 Volvo xp90. The contact stated that when servicing the vehicle, the technician discovered that the fuel tank was leaking. The vehicle was diagnosed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 133,675. Djr.