Diesel Fuel System Pre-heater Problems in popular cars
Diesel Fuel System Pre-heater problem is a common vehicle problem that happens to most car brands and models. The following is a sample list of Diesel Fuel System Pre-heater problems reported in most popular vehicles.
Diesel Fuel System Pre-heater problem of GMC C2500
The car was a 2001 GMC 2500 hd. The VIN of the problem C2500 is 1GTHK23101_. While replacing the fuel injectors under a special injector warranty, the dealership broke a glowplug off and called to say I need to replace the cylinder head at my cost. Call GMC customer support who say due to the age and mileage 2001, 124500. That the corrosion of the glowplug and the fact it seized in the cylinder head is not there problem, even though they are the one who designed the engine. They said that it's at my cost for a new cylinder head which was quoted to me over the phone at a price of $1,800. 00. This issue happened on Mar. 6, 2008.
See
all problems of GMC C2500 and
all Diesel Fuel System Pre-heater problems of GMC C2500.
Diesel Fuel System Pre-heater problem of Jeep Liberty
The VIN of this vehicle is 1J4GL58526_. Today my 2006 Jeep Liberty diesel would not start. I discovered that the fuel filter had lost prime and there was diesel fuel leaking from the heater plug connector that is connected to the fuel filter housing. I unplugged the connector and noticed that the yellow plastic plug head showed noticeable signs of scorching (brown discoloration) around the pin holes. Also, when I disconnected the plug there was a hiss of air escaping from the system. No doubt this air leak is what caused my initial problem of lack of fuel pressure causing the vehicle to fail to start. However, the bigger concern here is that the system is leaking fuel and the heater seems to be shorting out its electrical components which is a very dangerous combination. This problem occurred on 10/05/07.
See
all problems of Jeep Liberty and
all Diesel Fuel System Pre-heater problems of Jeep Liberty.
Diesel Fuel System Pre-heater problem of Jeep Liberty
The car involved was a 2005 Jeep Liberty. Vehicle identification number (VIN) of the vehicle is 1J4GL48535_. Leak from fuel heater electrical connection caused vehicle to stop operating. When the system is primed fuel is sprayed into the engine compartment. I talked to Chrysler and they said this was not covered after 36,000 miles. The electrical connection is burned and damaged. It was Sep. 13, 2007 when this diesel fuel system pre-heater issue occurred.
See
all problems of Jeep Liberty and
all Diesel Fuel System Pre-heater problems of Jeep Liberty.
Other Diesel Fuel System related problems of all cars:
| Problem Category | Number of Problems |
|---|---|
| Diesel Fuel System problems | |
| Diesel Fuel System Tank Assembly problems | |
| Diesel Fuel System Pre-heater problems |