Table 1 shows one common other fuel system related problems of the 2021 Chevrolet Malibu.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
Took my car for an oil change 4/17/2026 dealership stated I had a recall on the 21 chevy Malibu for fuel injection module, they could not do the recall repair because they did not have the part. So the lady called me. 4/21/2026 to make appointment for recall for 4/23/2026. But later that day on 4/21 my engine light came out and my car started having problems. When ran a diagnostic it gave a code for the fuel injection.
My car stalls, jerks, and shuts off when in drive. More specifically when I turn it on, shift it in reverse, reverse, shift into drive. I press on the gas and nothing. Car doesn't move. I put it back in park sometimes it'll shut off most of the time it'll jerks and jerk while I tap on the gas, then make a big stutter like power is low gas doesn't seem to be working with the pedal then it makes a huge jerk before it goes into drive. This has become an everyday thing. Car has shut off when auto off is on while at a stop. There's a huge creaking coming from the under body. Almost feels like something is going to fall out from under me. Every turn, bump, speed bump sometimes just at a stop then going into drive will create the loudest sound. Also sometimes it says I need to shift into park when I am in fact in park. When looking up common potential recalls my car checks almost every box that were stated online.
I was driving and car suddenly reduced speed,engine light came on and message came across dash “engine power reduced” and a text was sent to tell me I have a transmission issue. Now car won’t drive past 25-30mph dealership indicated this is a faulty gas pedal which cost over $600 to repair. Did my research and this is apparently a “known” problem common in 2016-2022. Vehicles but is not an official recall. Also dealership said only “certain” VIN numbers with this problem are covered. I have a 2021 and I am not one of them. Not fair. It’s a known problem it should be fixed.
I was driving on the highway and the check engine light came on. The car slowed down due to lack of power. I got off at the nearest exit and the car stalled. I tried to start it but it kept clicking rapidly. The car died at a dangerous intersection so I put my hazard lights on and called 911. The police arrived and asked me to put the car in neutral, but it wouldn't shift. The officer was able to start the car, and I drove it to a mechanic. He ran a diagnostic and the fault code is p023f, fuel pump secondary circuit/open. There are no open recalls on the vehicle, but this is a major safety issue. If I hadn't been able to get off the highway it could have caused a major accident. Also, when I put the car in park and turn it off, the dashboard tells me shift to park even though the car is already in park.
Dear NHTSA: I am submitting this complaint because my vehicle, a 2021 Chevrolet Malibu (VIN [xxx] ), is included in emission recall n252516900 issued by general motors concerning the fuel pump power control module. Despite that inclusion, I have experienced the following: - a prior near-fatal incident in 2023 when the vehicle unexpectedly shut off while stopped at a red light (engine stall) due to the root defect. - the dealer has informed me I now need a new 12-v battery (just over one year old), a new ac compressor, and a new drive/serpentine belt. - the defect referenced in the recall (interruption of fuel flow) is reasonably the root cause of these consequential failures (battery stress, accessory drive stress). - I have been without the vehicle for 11 days, have not been provided adequate interim mobility support, and have not received timely resolution from gm under my case #xxx (agent jasmine who has followed her company's protocol while remaining helpful and empathetic; supervisor stephanie called October 17, 2025). Requested relief: 1. That gm be required to pay for the recall work (module replacement) *** reimburse/cover the consequential damage (battery, compressor, belt). 2. Interim remedy: loaner vehicle or rental reimbursement for days without vehicle. 3. Acknowledgment of the safety risk posed by the defect and record of the stall incident. Thank you for your attention to this matter. Sincerely, [xxx] [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
While driving when coming to a stop, my brakes became stiff causing me to almost hit the vehicle in front of me. Also, the car has been stopping while I am driving and on busy roads when I am at a stop light and press the accelerator to proceed, the vehicle just stop and cuts off completely leaving me stranded while trying to restart the vehicle. Also the vehicle has a long crank before it starts. I have been without my vehicle for a month now and it’s very inconvenient due to these issues. It has been to the dealership where they quoted me over 8,000 to fix the problem.
It says that my engine had a problem. It told me to press my brake to start my car. But then it just kept shaking like it was trying to start. I have also had a notification saying to put my car in park when it already was. Today my car just stopped in the middle of the road in heavy traffic. We could have been hit getting out of the car or someone could have hit my car. It was towed to the local Chevrolet dealership to get checked out to see if it could be a recall. I don’t know what is wrong with it yet. There were no warning lamps prior to the failure. They appeared right when it happened.
The computer was not recognizing my car being in the correct gear shift. It did this for a few days until finally, I couldn't drive it. The car would not recognize any part of the gear being in the correct position. The car would not move forward or reverse, resulting in a tow. The mechanic at reed lallier Chevrolet in fayetteville nc was even able to guess my car make and model from the symptoms I reported (which was later discovered, in my case, the gear shift link had loosened), and confirmed that if this happened while in motion, it would have been very dangerous. He also said they had 3 other cars that same day that had different causes but the same exact faulty gear recognition, with all of them being recent-year Malibu Chevrolet models and the following day when I was doing my follow-up call concerning my car, 2 more were brought in with the faulty gear recognition issue.