Front Suspension Lower Control Arm Problems of Chevrolet Malibu

There is a clunking noise in the front suspension. It has been to 2 different dealers on three occasions. The noise still exists.

See all problems of the 2003 Chevrolet Malibu 🔎.

The lower control arm produces a popping sound when turning in either direction. A recall was issued, however, this vehicle was not included in the recall due to VIN.

See all problems of the 2002 Chevrolet Malibu 🔎.

The lower control arm made a noise while driving, which caused the steering wheel to shake.

Control arms, r & r arm, control lower-one side . Both went out, both needed replacement.

See all problems of the 1997 Chevrolet Malibu 🔎.

I have a 1998 chevy Malibu with 60,000 miles. The problem started at about 50,000 miles. Both front lower control arms started to rattle over cracks and bumps around July 2001. It has steadily become worse and is to the point I can hear a loud clunk even over expansion joints or when it shifts gears during acceleration. I have heard from several other owners who have experienced the same problem, some with fewer miles. In all cases Chevrolet refuses to take any responsibility and says we have to replace with newly designed control arms at our own cost. I am going to replace them for fear that the bolts are going to break from the excessive movement allowed by the inferior bushings used in the original part, but I think gm's decision to not recall this obvious safety hazard should be questioned. They have admitted there was a design flaw by producing a redisigned part, why should they not recall it?.

See all problems of the 1998 Chevrolet Malibu 🔎.

Front suspension loose and banging when going over bumps. Dealer replaced lower control units 8/16/99. Starting to experience severe steering vibration at 60-70 mph, again. This is how the original problem started.

Front suspension malfunction. Dealer advises owner that the dealership has replaced 5 sets of lower control arms on this model.

The vehicle has a real bad squeaking problem due to the independent front suspension. The vehicle has been brought to dealership (5) times for suspension problems in the last (6) months. Lower control arm and bushings have been replaced (4) times.

Lower a arms failed. Nlm.