Diesel Fuel System Related Problems of the 2003 Chevrolet Silverado

Table 1 shows one common diesel fuel system related problems of the 2003 Chevrolet Silverado.

Table 1. Diesel Fuel System related problems of Chevrolet Silverado

Problem Category Number of Problems
Diesel Fuel System problems
4

Diesel Fuel System problem #1

On April 19, 2012, the Chevrolet dealership advised me that two or three of my 2003 Chevrolet Silverado diesel fuel injectors, part# 97729095, needed to be replaced and recommended all eight fuel injectors should be replaced at a cost of $5,260,18. I asked if this repair was covered by Chevrolet and the dealer representative said my truck did not qualify because the time limit had expired. He said if the vehicles fuel injectors had failed within the first 200,000 miles or within the first seven years they would have replaced the fuel injectors at no cost. On that date, April 19, 2012 my vehicle had 36,273 miles and was 9 years old, I asked why the dealership hadn't notified me of this problem and they said it was not their responsibility to notify me and refused to replace/repair the defective fuel injectors.

Diesel Fuel System problem #2

Had fuel in oil new injectors replaced and 5000 miles later had to replace fuel injector pump leaking on bottom. Now truck lose fuel from filter and has to be hand pumped to start truck can sat for days and be ok or may sat for just couple hours lose fuel pressure. Have also had to have steering pump replaced.

Diesel Fuel System problem #3

Steep hillside incline / decline failure of sensor for fuel gauge/ do not know the amount of fuel in the vehicle computer failure, leaving to being stranded repair of failure cost of 600. 00 dollars usda / complaint is as follows:off road travel would be impossible due to in the event you are in a steep incline or decline it would cost $600. 00 to repair. Really not cost effective.

Diesel Fuel System problem #4

At least one fuel injector failed on my 6. 6, duamax. 3700 miles out of warranty. Can not replace just one. Gm says to replace all. No way to test injectors. Injectors are not stocked because of high price. Down 13 days because parts not available.


Diesel Fuel System related problems in other Chevrolet Silverado model year vehicles:



Fuel Economy of Silverado Vehicles
Silverado Service Bulletins
Silverado Safety Recalls
Silverado Defect Investigations