Table 1 shows one common steering related problems of the 2023 Chevrolet Silverado 1500.
| Problem Category | Number of Problems |
|---|---|
| Steering problems |
My 2023 Chevrolet Silverado 1500 experiences an intermittant, uncommanded mechanical drivetrain lockup and severe binding when accelerating from a complete stop. The vehicle rolls fine in a straight line for several feet, but the exact moment the steering wheel is turned slightly (a couple degrees), the drivetrain violently binds up. This creates resistance in the steering and acceleration, as well as a severe physical and audible metallic clunking slam and massive shockwave vibrations felt directly through the steering wheel, floorboards, brake/gas pedals, and driver’s seat. During the last event, the vehicle threw a "service 4 wheel drive" dash message and refused to shift out of "auto" mode back into 2wd. Because this is a pure mechanical interference/binding issue, it does not consistently throw active electronic trouble codes. A standard obd2 code scan will show nothing. After turning the vehicle off for several hours and testing again, the problem persisted. After towing the vehicle to a dealership (6/10/2026) it sat for at least 5 days before dealership service looked at it. By this time, the active warning lights cleared. My initial servicing dealership refused to perform physical hardware or fluid diagnostics under my factory warranty, stating they would not look at the vehicle unless I paid $860 out-of-pocket or until the drivetrain "completely grenaded" on the road. Because this uncommanded lockup restricts my ability to steer the vehicle safely from a stop, it presents an immediate crash hazard. At the direction of general motors corporate, I am escalating this issue and moving the vehicle to a secondary certified facility (feldman Chevrolet of novi) on June 23, 2026, for a formal physical hardware and fluid tear-down inspection.
On [xxx], my 2023 Chevrolet Silverado 1500 lt caught fire while parked in my residential driveway at [xxx] . The vehicle had been started approximately 10 minutes earlier using the factory-installed remote start system. The vehicle was unattended at the time. My neighbor noticed the vehicle on fire and called 911. The andover fire department responded and extinguished the fire. The fire department indicated the fire appeared to be electrical in nature. The fire appeared to originate in the dashboard and steering column area based on visible damage and fire progression. The vehicle had approximately 60,000 miles and was properly maintained. There were no prior warning lights, messages, or symptoms before the fire. The remote start system was factory-installed and not aftermarket. The vehicle is currently available for inspection by insurance, manufacturer, or investigators at [xxx] . The vehicle is likely a total loss due to the extent of the fire damage. This incident posed a serious safety risk as the vehicle caught fire spontaneously while parked near my home. The fire could have spread to my residence or caused injury if someone had been inside or near the vehicle. The fire department responded, and an official fire report is pending. Insurance claim has been opened and inspection is pending. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
On 1/21/26 traveling on a 4 lane divided highway, vehicle stalled, several warning lights came on and vehicle came to a complete stop in driving lane. Vehicle locked in park and could not put vehicle in neutral to push it out of highway. Several vehicle swerved to avoid and until tow truck came blocked a lane. It was about 3:30pm fortunately. So vehicle was visible and no accidents to our knowledge occurred. Thai created a dangerous traffic situation. It was caused by a fuel pump control module whig was repaired 2 days later at local chevy dealer. We were advised there were no recalls on this part but it is a common problem. Gm should somehow find a solution and repair said problem.
The contact owns a 2023 Chevrolet Silverado 1500. The contact was driving at approximately 35 mph, and the steering wheel was difficult to maneuver, causing the vehicle to veer off the road and crash into a tree and a steep ditch, where it came to a stop. The air bags did not deploy. The "service power steering" message was displayed on the instrument panel. The contact sustained injuries, including arm lacerations. The contact did not seek medical attention. A police report was not filed. The vehicle was towed to an auto body repair shop to get a diagnosis; however, the vehicle was not diagnosed as of yet. A dealer was contacted and went to the auto body repair shop to diagnose the vehicle; however, the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the dealer. The failure mileage was approximately 16,000.
I was driving on the interstate when the power steering failed. I was on a straightaway so I was able to force the vehicle to the side of road and have it towed. If I was in a corner, I would have crashed. It was repaired at Chevrolet dealership.
Vehicle sways/wobbles on grooved pavement. Magnified immensely when towing a trailer. Threatens to pull you into other driving lanes. Service technician and service manager at dealership state it is a known condition with the type of tires Chevrolet has put on the vehicle and that Chevrolet is refusing to do anything about it. Multiple dates and is repeatable.