general problems of the 2024 Chevrolet Silverado 2500 - part 2

The contact owns a 2024 Chevrolet Silverado 2500. The contact stated that while hauling a travel trailer at various speeds, the check trailer wiring warning message intermittently flashed on the instrument panel. The contact had taken the vehicle and the travel trailer to the respective dealers; however, neither dealer were able to determine the cause of the failure. Upon investigation, the contact discovered a TSB: 23-na-113 which he linked to the failure. The bulletin stated that the travel trailer brake might become disabled due to a solar panel battery charger. The contact stated that whenever the trailer battery was fully charged and had a higher charge than the vehicle’s battery, there could be a back feed into the trailer brake power module causing a shutdown. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 1,500.

While pulling fifth wheel camper the the electronic brake controller looses connection and brakes on the trailer do not work leaving only the truck brakes to stop both truck and trailer. General motors claims this is caused due to the solar panel on the trailer charging the trailer battery more than the truck battery which back feeds into the system. This problem only occurred on the 2024 models. The same trailer was pulled with a 2021 model with no issues. This is a known problem which Chevrolet has a service bulletin stating such. Reference document # 6379278. At this time there has not been a fix. This is a safety hazard because there is no warning as to when the trailer brakes will stop working.

When truck is connected to a trailer with electric brakes, intermittently a check trailer wiring warning flashes on the dashboard screen. When this happens you do not have trailer brakes. It has happened on multiple trailers with 7 pin connections. I have taken it to the dealer twice with no fix other than gm recommending a non gm trailer receptacle. I have taken my trailer to the dealer and they could find no problems. Basically the 2024 Silverado 2500 hd when hooked to trailers with industry standard 7 pin 12 volt receptacle loses trailer brakes. This condition potentially is fatal and a definite hazard to public safety on roads. Problem was reproduced at the chevy dealership in pensacola FL. The problem was reproduced on multiple trailers at great american RV in defuniak springs FL.

While towing my fifth wheel trailer, the electric trailer brakes module shuts off with a message "check trailer wiring". When the module shuts off, the trailer brakes do not actuate relying fully on the truck to stop as the trailer brakes will not work. The plug was firmly seated and it caused issues whether using the in bed plug or the bumper plug. After some time, the message would go away and the system would display the message "trailer connected" and the trailer brakes would work again. After some time, the process would repeat several times (30-40 times) primarily from mid morning to evening. I verified plug tightness and applied dielectric grease to ensure a good connection and that did not improve the issue. The trailer is 1 year old and was pulled with 3 other trucks (2 Dodge and another chevy) with no issues at all. I was able to locate a gm bulletin numbered "document 6379278" that references this problem and states to disconnect the trailer solar panels while a fix is developed. This was only found on an RV owners forum. I was able to disconnect my solar panels on my trailer and the issue was no longer present with my brakes working properly and no error messages for 10 hours of driving. This is a significant safety issue and needs to be made abundantly clear to drivers who haul trailers. Not all solar panels are easily disconnected and should be done by a qualified electrician due to the potential hazards of their voltage. Additionally, not having trailer brakes while driving on the interstate is a significant safety hazard that greatly increases the chances of an accident as the brakes would stop working without warning including while in use. My vehicle is a scheduled for an inspection at the dealer on 7/22/23.

Truck has been in and out of the shop since July. For more than 70 days total. I received a printout from a chevy dealership in georgia that indicated the main computer system lost communication with other components 11 times. It indicated it lost communication with the brake system control module three times and lost communication with the engine control module twice. Not sure exactly what that means, but it sounds rather serious. I've been trying since July to get gm or the dealership to buyback or replace my vehicle. Neither had any interest whatsoever. After I provided the attached photo to gm, they decided to buy my vehicle back. Seems that this issue is bigger than I know and surely needs some oversight from NHTSA so no one gets seriously injured due to gm's carelessness to address issues when they were brought up.

On July 1st, 2023, I purchased a 2024 Chevrolet Silverado 2500 from orielly Chevrolet in tucson, arizona. On July 2nd, 2023, an error message popped up on the dash, “park assist blocked see owner’s manual”. It continued to happen on and off til this very day. The dealership "attempted" to fix the issue, but it obviously hasn't been resolved. Due to equipment being faulty, the chances of an accident whilst back up are significantly increased. At one point on this ordeal, the truck was in the shop for 61 days. It had been in my possession for 18 days. I am currently in the process of a buyback for the vehicle. I had to hire a lemon law attorney. A supervisor from gm advised that gm is refusing a buy back for the vehicle. The vehicle also displayed an error, "key not found" while I was driving at 50mph. A bit unsettling. That error showed up twice on the dash. The dealership said they fixed the issue with a software update. Recently, the vehicle has a ticking noise on the left side of the engine, and the engine idles so low, that it feels like it's going to stall. Those issues haven't been addressed at the shop, because I start a new job on Monday(12/4) and had to drive over 2k miles to get here. Thankfully the truck made it. Not a concern I should have with a brand new vehicle.

The gm brake controller will disconnect with the trailer being pulled. You get a message on the information center that the brake controller has lost connection with the trailer or no trailer brakes are available, something to that effect. This has happened up to 5 times in one day. You never know when this will happen. Pulling a 7,000lb trailer and not knowing when you will have 'no brakes' is dangerous. I bought the truck to pull my RV trailer, now am afraid too. I brought my truck into a dealer and first was told "the issue is in the trailer". There is a bulletin saying the issue is do to 'the solar panels or solar generator', I have nether, just one lead acid battery. Then was told 'they don't know what they can do'. I've been in contact with other that have the same make, model, and year that is having the same issue ! I now have a very expensive vehicle that I can't do with what it was advertised it could do !!!.

Brand new truck, 1st time towing through mountains of kentucky, we kept getting "check trailer wiring", "trailer brakes disconnected" "service trailer brakes" I did research and took the truck in for service. They found nothing wrong, but said we should get an adapter and gave me the name of two. We had the camper checked as well, no issues. Many complaining on blogs about this issue and many have also been told to get an adapter. Really? why would I need a $200 adapter and the fact they already knew which two I should buy, tells me, they know its an issue with the vehicle. Pretty scary when we had to come to a stop on the freeway and we didn't have trailer brakes. Never had any issues pulling it with our 2021 silverado 1500. This is really dangerous.