One problem related to dash wiring has been reported for the 2005 Chrysler 300. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Chrysler 300 based on all problems reported for the 2005 300.
There was a complaint filed on this vehicle odi 10125270 concerning the air bag light coming on and staying on. The dealership found out it was the clock spring, and they have replaced it 3 times , but it kept failing. Currently, the vehicle is at the dealer, the dealer stated that there was inferior wires used on the wire harness. Dealer was to replace entire wire harness under dash board. There was going to be a week or two delay in getting the parts. Then there was concern that if there was inferior insulation involved with the wire harness this could cause severe problems such as a fire. The vehicle could not be filled through the fuel pipe to the gasoline tank and the fuel gauge was stuck on full. Upon examination by the dealer, it was found the vehicle would not take any gas. The dealer decided that the vehicle needed a kit to be placed on top of the fuel tank.