Power Steering Pump Problems of Dodge Caravan

There is a serious issue with the steering rack an pump on the 2006 Dodge Caravan. This appears to be a widely reported issue online. Dodge has not taken any action to recall.

See all problems of the 2006 Dodge Caravan 🔎.

I have a 2005 Dodge Caravan that I have had for 2 winters now and both winters it has blown the power steering pump leaving a giant red puddle on the ground and a giant repair bill on my wallet! I have discussed it with my mechanic and was told to expect this at least once a year! I do not find this acceptable. This time it happened in my driveway but last year it happended on the road and almost landed in the ditch as a result!.

See all problems of the 2005 Dodge Caravan 🔎.

I have a 2002 grand Caravan. There is a loud whining sound from the steering column. I have complained of this problem from the time it was purchased. Originally the dealership said they could not duplicate my complaint. After the warranty expired I was told there was an internal leak in the steering column and the rack, pump and lines needed to be replaced. This was done and the noise is still there.

See all problems of the 2002 Dodge Caravan 🔎.

Aug. 20, 2007 - steering has been locking up daily, for the past year on my 2001 Dodge Caravan. It is obviously a serious and constant problem with these vehicles. I have had the issue looked at by various mechanics and none can identify the problem for sure. They all say that it is happening too often - it's very dangerous but they can only 'try changing the rack or power steering pump or flushing the fluid. . . . ' no guarantee that it will fix the problem. Chrysler has been very negligent with this issue. I encourage everyone to vote with their feet and go elsewhere when purchasing your next vehicle - not Chrysler.

See all problems of the 2001 Dodge Caravan 🔎.

1991 Dodge Caravan. Consumer writes in regards to anti lock brake system recall and seeks reimbursement for repairs. The consumer stated he paid for the repairs on April 20, 2006 and was charged $376. 73, even though a recall had been issued. The consumer experienced abs problems again in December 2013. The consumer stated the recall letter stated if the problem occurred again, Chrysler would cover any repairs. The dealer informed the consumer, he had to pay $112 for a diagnostic test, to see if the problem would be covered, under the recall. The dealer then informed the consumer, they didn't have the equipment to test his vehicle, due to the age. However, a few days later, the dealer informed the consumer, they had the equipment, but it would cost $336. The consumer declined the test. Also, the transmission, starter, fuel pump, ignition coil blocks , serpentine belt, pulleys, power steering pump, and radiator were all replaced. Updated 04/16/14.

: the contact stated the engine makes a loud whining noise while driving. The dealership determined the power steering pump was installed incorrectly. The dealership is currently unable to repair the problem.

The contact owns a 2003 Dodge Caravan. The contact heard a loud noise coming from underneath the hood. The noise becomes louder when the vehicle is cold. The dealer stated that the power steering pump was defective and replaced the lines on the power steering pump. However, the dealer failed to replace the power steering pump. The current mileage is 51,000 and failure mileage was 35,000.

See all problems of the 2003 Dodge Caravan 🔎.

: the contact stated while turning the steering wheel to the right or to the left; a whining and grinding noise is heard. The vehicle was taken to the dealership four times. The water pump, the power steering pump and the alternator have been replaced. The repairs have not corrected the problem. Updated 2/24/2006 -.

2003 Dodge Caravan had problems with the power steering pump. The consumer stated when he made a left turn a loud noise was heard.

When driving any speed steering wheel jerked and made a squeaking noise. Dealership informed the consumer that the problem perrtained to power steering pump failure. The problem was not resolved.

This family car is not a vehicle we drive every day. On (9/10/04), we went to use this car with less than 72,000 miles on it, and when we went to turn the steering wheel we heard a squeling noise from the power stering unit. We found an area of seepage of stering fluid under the vehicle. After further investigation we had found it to be coming from the area of the base of the power stering pump casting. The leaking fluid is actually flowing through the voids in the metal of this unit. Not only is this a hazard to the operation of the vehicle and its passenger's, it is a hazard to other vehicles on the highway. I am very concerned with the use of poor quality parts and used in our transportation industry. If a person is driving one of these vehicles and one of these units fails it could cause catasrophic damage to the people involved. I do feel obligated to inform you of this defect. As of 8/17/04 this vehicle will have this defective power stering unit replaced at the Chrysler dealer in keene nh. I am not aware if I will be able to get this unit back from the dealer when they replace it.

See all problems of the 1999 Dodge Caravan 🔎.

While driving the consumer heard a groaning noise. . The driver started to pull of f to the side of the road when she experienced a momentary loss of control. When the consumer's husband checked the power steering reservoir he noticed it was dry. Upon further investigation the consumer found out that the bottom of the power steering pump had corroded through and the fluid leaked out through the housing.

See all problems of the 1998 Dodge Caravan 🔎.

Power steering pump rust through made as a 2 part assembly the shroud around the power steering pump is made from a thin sheet medal with no rust protection. The part simply rusted through and started leaking power steering fluid.

The vehicle continued to experience problems with the power steering pump, which was replaced 4 times.

Loss of control while attempting to turn caused vehicle to veer into oncoming traffic. Vehicle towed to dealer, and infomed consumer that problem was due to steering belt tensioner needing replacement. Feel free to provide any further details on this matter.

While traveling noticed a loud noise, could not steer vehicle. Dealer has been notified. The dealer replaced the steering pump and the steering rack.

Power steering pump pulley broke, causing vehicle to lose steering control . This could have caused an accident.

See all problems of the 1996 Dodge Caravan 🔎.

Belt tensioner and serpentine drive belt failure, tension mounting belt is spontaneously sheared off and the belt becomes torn apart, resulting in loss of power steering and power braking.

While driving this vehicle at about 35mph. The power steering belt has popped out several times, causing loss of steering and making the turning very hard. Dealer has not been contacted.

While driving 15 mph lost steering. Dealer replaced tensioner belt that had fallen off. This had happened in December 2000, at 30000 miles. During routine inspection on 15 November, 2001 dealer noticed tensioner belt needed to be replaced a third time.

See all problems of the 1997 Dodge Caravan 🔎.

Power steering has regularly cut off when turning at very low speeds and backing up. Vehicle has been returned to dealer 10 times. Dealer has replaced tie rods, power steering pump, belt, tensioner, steering rack,and steering column. Problem is intermittent and dealer states it does not do it when test drive is taken.

While driving through standing water at right front wheel, water spashes onto power steering belt, resulting in temporary loss of power assist steering. TSB service bulletin number: 19-01-97.

Belt tensioner pulley malfunctioned causing the belt to slip or come off resulting in no power steering. Nlm.

Power steering belt broke off.

The steering belt has broken twice, and left the van with no steering.

Owner states that his sliding door cannot be opened from outside, he notes that it must be opened from inside, that in the event of an emergency he may not be able to open door.

While driving on wet pavement power steering belt becomes wet and causes complete loss of steering control.

While the vehicle was parked consumer noticed that fluid was leaking from under the vehicle. Consumer took vehicle to a body shop for inspection, and mechanic determined that steering power assist pump needed to be replaced.

Steering belt tensioner bolt sheared off, causing vehicle to los econtrol. Delaer replaced the bolt.

There is a leak in the power steering pump making it difficult to steer vehicle. Dealer has inspected vehicle. Dealer to replace power steering pump.

Steering belt tension bar broke, causing a loss of vehicle control and power steering.