Other Fuel System Tank Mounting problems of the 2006 Dodge Charger

Each time I refuel my vehicle the vehicle stalls while in motion on a highway. This happens with any amount of gas I put into the tank. The vehicle stalling after refueling has occurred at various speeds ranging from 0mph at a complete stop up to 50mph.

My 2006 Dodge Charger rt with the road and track option will intermittently loose power and often die after filling gas tank. Even if you don't completely fill it still will die unexpectedly. I never top the tank off with more gas. In addition when car dies going around a curve, the power steering goes out making driving really dangerous. The engine dies at nearly any condition. When traveling at highway speed, after accelerating after stopping. It happens most during acceleration after turns.

Engine stalls several times immediately after filling gas tank. This is very dangerous because you loose steering and power brakes in traffic. The Dodge dealer says that it does this because there is gasoline in the vapor canister. I believe this is because something in the fuel tank is causing fuel to get into the canister where it does not belong. Changing the canister is not going to solve the problem. I am afraid to drive the car and I'm afraid to buy another Dodge or Chrysler.

Car stalled 100 feet from service station after fill up with premium gas. Since then the car is run with 1/4 to 3/4 tank of gas and never filled completely up. Car shuts off during acceleration from stop light numerous times. Car shuts off at various speeds and starts back running with a surge in acceleration. This happens with and without cruise control on. Going up or down hills and on level pavement. Amount of gas in tank does not make a difference. Changed to different key no keyring without change in symptoms. Mobile 1 synthetic oil changed regularly. Car is driven by older driver within speed limit. Purchased car new with no miles on it. This is a safety issue that will get someone killed. Last drive was 20 miles. Car shut down and restarted itself 5 times going down the road at 40 mph. I want to repair the car but Chrysler/Dodge will not issue a fix for this problem. First Dodge I have ever owned.

After filling gas tank completely, car started stalling going down the road. Continued to stall at stop light and in parking lot and would not stay running unless hitting the gas pedal. Problem seemed to resolve itself after a few miles. Same exact issue has happened multiple times over the last few months, but only when filling the gas tank completely. When only putting partial amount into tank, this issue does not seem to be an issue. Have done research online and it seems to be a common problem with the 2006 Charger and 2 other Chrysler models. Spoke with firestone in columbus GA and was advised there was a service bulletin regarding this issue and that my gas tank needed to be replaced. Contacted a Dodge dealership in columbus GA over 2 months ago and was advised fuel tank is on national back order.

First time it staled was when I filled tank up and got imediatly to highway car stalled as I tryed to merg to highway speed . Almost got run over by a tractor trailer behind me. It took a while till I discovered that a fil up will cause Charger to stall happened many more times after I found that it was gas fil up causing the stalling that is the only problem with Charger. I can only get small amounts of gas at a time. Help me. . . Please.

Problem occurred and continues to occur after filling up the gas tank. First instance was in November 2010 and most recently December 2013. Car will stall numerous times until some amount of gas is burned off after driving. First instance occurred making a turn in front of a railroad track. Other instances have been on a freeway in heavy traffic causing me to have to pull over. Car can restart on the first re-attempt or take up to 4 attempts. Car will usually stall again seconds later. A workaround is not to fill up the tank all the way (to the auto shutoff of the gas pump) but this doesn't always work. This is with a 2006 Dodge Charger with a 5. 7 liter hemi. Chrysler denied the issue back in 2010 although the problem was starting to be documented on the internet at that time.